Touran 1.9TDI Throttle Sensor/Glow Plug Fault

[Kiyonari]

Hi,

My 2009 1.9TDI has intermittent power loss problems, feels like limp mode but it only lasts 1-2 seconds and goes, always under initial acceleration at low revs, coil light on dash starts flashing, but then drive normally for rest pf journey. The problem can be gone for a few weeks at a time then return. It recently had the vacuum pump replaced as this was leaking oil everywhere. It hasn't had the fault since for three weeks until today where its started again. I have scanned it and it always throws up the following faults:

16610/P0226 - Throttle Pedal Position Sensor (G79): Implausible Signal

P161A/005658 - Glowplug for Cylinder 1 (Q10): Open Circuit

P161B/005659 - Glowplug for Cylinder 2 (Q11): Open Circuit

P161C/005660 - Glowplug for Cylinder 3 (Q12): Open Circuit

P161D/005661 - Glowplug for Cylinder 4 (Q13): Open Circuit

Garage wants to change all the glow plugs but my thoughts (with limited car knowledge) is its something to so with the throttle position sensor and thats causing the plugs to throw up the fault??

Any advice much appreciated.

[Crasher]

It needs glow plugs anyway, fix the other issue and the light will still come back on. The throttle pedal acting up is very common at this time of year as the sender is under the pedal and gets wet, daft design.

[Kiyonari]

Thanks crasher, what symptoms would bad glow plugs cause, is that what is causing the loss of power rather than the sender?

[Crasher]

The glow plugs could cause starting problems and will raise the tailpipe emissions as they are used as part of the combustion process, the pedal will cause limp mode.

[Kiyonari]

It does stink a bit like, ill do em at weekend 👍👍 thanks

[Kiyonari]

Even though coil light (squiggly line) goes off and its fine for two weeks, would the light not be on all the time? ill change them i just like to learn why so i can help someone else in future 🤘🤘

[Kiyonari]

Also rear left brake light fails all the time and the glow plug light flashes not static

[Crasher]

Check the earth pin on the bulb holder and plug for burning.

[mickeybo]

Can you yourself post up your engine code as there is 5 off 1.9 codes for these

[Kiyonari]

The dreaded BXE