No power to the ECU

[jon0881]

My 2011 2.0 TDI come to a stop and VCDS said it could not talk to the ECU and it had a clutch switch fault (short to positive). The garage replaced the switch and the ECU was still a no go. They found that if they forced a conenction from the ecu relay the ecu powered up and all was well. They then said that the ECU itself is responsible for switching the relay and it wasnt doing that. They said they tested the relay too. So i send the ECU away and got a refurbished one reprogramed from my old one and the problem is still there. They say the ECU is not earthing out the switch in the relay so the ECU is not fully powering up. Theyve checked all the wiring they think is involved and found nothing wrong.

Does anyone have any ideas as im bloody lost here.

Thanks

Jon

[zollaf]

how can the ecu power up the relay that powers it up.. ?? i would try a new relay myself first off. that will be powered from the ignition switch, so could be that, but i would need to study a wiring diagram to suss it out properly, which is what the garage should have done.

[jon0881]

This is what the garage is telling me that VW work differently and the ecu earths out a positive to the relay to juice up the relay. Low voltage switch I guess

[zollaf]

so with no power the ecu earths out a relay to swicth itself on. hmm, righto..

[zollaf]

has anyone done a full fuse check just in case the clutch switch has blown one ? unfortunately i don't have a wiring diagram so can't check for you, but when you tun the ignition on that will power the ecu relay which then fires up the ecu.

[jon0881]

Strange isn't it but it's what the garage tell me. I wish it was the relay

[zollaf]

well find another garage then.

[jon0881]

I checked as many as I could but had no map to go from. Not sure what's been done since. Would a broken fuse mean that the car wouldn't start with the wire instead of the relay? I guess so if the garage didn't get the right feed from the ignition.

[Crasher]

The company you sent the ECU to, are they located in Heanor?

I will assume the engine is a CFFB code without stop start.

The engine ECU has a main power feed called Line 87a from fuse SB14 in the engine bay fuse box (called SB) which splits into three separate feeds to the ECU. Fuse SB14 gets its power from the Line 30 J317 relay at position A2 on the fuse box and this gets its power from a connection on the front of the under bonnet fuse box which is direct to battery. Is this the relay they are jumping across? This relay gets its trigger side power feed from fuse SB13 and this is also the permanent Line 30 power feed to the ECU for memory saving purposes, the wire is only 0.5-mm core. The slightly obtuse point is this relay is earth triggered by the ECU which it is powering so it has to be powered up first to be able to do this by an ignition on feed from the Line 15 relay via fuse SC10 in the dash side fuse box, this relay is under the dash at position 2 on relay carrier 3 and has the number 645 printed on top, so is this the relay they are jumping across?

[jon0881]

Wow thanks so much for such a detailed reply. The relay they are bypassing is the one under the bonnet marked 370 8d0951253.

The garage is convinced it's the Ecu and still the Ecu (refurbed one) as the Ecu is not earthing out the feed to the relay. The Ecu people asked for it back to test it again but to be honest I'm loosing confidence in the garage as I think they and the Ecu people have different schematics. I don't even have a fuse map for the car (does anyone have one). The chats between the garage and the ecu people found that there is feed from the ignition to the ecu when the key is in. Despite them having different points to test that from their documents

thanks again a in for your help

oh the engine code is cffb but it does have stop start.

[Crasher]

There is no definitive fuse map for the four main standard equipment model fuse boards SA, SB, SC and SD, it all varies by equipment, so you have to look it up for each circuit and follow the current flow diagram. I personally love VAG current flow diagrams, I print them out and read them in bed.... :bigeyes:

That relay is now 4H0 951 253 and has 644 marked on top, this is the second revision due to reliability issues, it is £17.93.

Have patience with your garage, modern car electronics, especially the type 36 Passat, are incredibly complex and fussy, a lot of professionals are really struggling to keep up to the point that you could now do with a VAG specific electronics specialist on hand at all times and that's a £40K a year overhead so we older grease monkeys have had to try and cope. If they can fire the relay up by sneaking an earth under it to pin 86 (corresponding to socket 3), then the continuity of the wire from socket 3 (a 0.5-mm core black/grey) should be checked back to pin 69 of the larger, 94 pin, plug at the ECU before doing anything else.

In the last few weeks I have had a type 3C Passat totally shut the car down to to a faulty steering column lock and a Golf 5 lose all it's left side door functions for no good reason which came back after plugging in a new controller but then the full central locking system did not work, which it had, so I plugged the old controller back in and everything worked again! Cars are now a PC on wheels.

[jon0881]

Thanks. Those are some great suggestions I will look into further once I have the ecu back we'll both ecu's back now as I've asked for my old one back too. I love this car but it's been the worst car I've had for reliability. A common fault on the clutch chewed the bell housing up and it goes limp with an egr fault on long journeys. I just want it back now, it's been near 4 weeks

[Crasher]

The type 36 was a VAST improvement in reliability over the later type 3C from 2009 which itself was a huge improvement over the first type 3C Passat from 2006>2008 which, in my opinion, is the MOST unreliable vehicle VAG have produced in around half a century, I think only the K70 and closely related RO80 came anywhere near as being so bad, an absolute joke of a car.

[jon0881]

update.... the ECU guy predictably said its fine as was the old one so he is sending me my old one back to the garage. Back to the drawing board then. Ive passed those notes you sent on there crasher so i really hope they help them out.

Ive bought a copy of ELSAWIN but ive no clue how to get the information i need out of it as i dont know what the gearbox code is or the vehicle ID number. There are some good diagrams in there somewhere though!

one thing the garage did say was that worst case we might be able to take a feed from the ignition feed to the ECU to switch the relay. Im not sure if thats a good idea though

[Crasher]

They should not need to bodge it but a couple of years ago my friend had a relatively young A3 with the same problem and I diagnosed that the command wire in the harness was fractured "somewhere". As it was a sales car, he made up a jumper wire because the trader was not prepared to spend the money fixing it properly.

[jon0881]

Well I'm over 1 month without the thing now so I'm getting desperate. :)

[Crasher]

Have they tested the continuity of the relay trigger wire from the ECU to the engine bay central electrics?

[jon0881]

Yes he said the continuety from the ECU to the relay is good. I was thinking its an obsure earth elsewhere in the chain on the othre side of the relay maybe, unless that also goes back to the ECU.

[Crasher]

The black/grey relay trigger wire from the ECU is direct from the ECU with nothing else that can interfere so if the relay can be driven by giving it an earth, the ECU is not providing it with an earth to trigger it which means the ECU is not powered up or faulty. PM me your email and I will send you the wiring diagram.

[jon0881]

Between the garage and the ECU guy they determined the correct pin for the ignition feed is reaching the ECU, this is where they will take a switched relay from if they cannot find the issue soon, so the ecu should be getting something. I didnt fully understand the ELSAWIN diagram i sent to the garage but are you saying the 2 wires to the relay to switch the relay are from the ECU?

[Crasher]

So you got Elsie working... Lets make sure we are on the same page (literally), a 2011 with a CFFB engine and stop/start?

[jon0881]

Correct. I think I just wrote out the whole flow starting from pin69 you mentioned. If it matches the document you send I'll post it up here. I got a spare relay today to try as I just want to rule it out. I'm fairly sure he said the positive side of the relay is there and it's just the switched earth missing which to me can only be the ecu, the relay or the short wire connecting the two. All of which are meant to be fine.

I actually enjoyed doing it too :)

I checked a 2011 Passat 1.6 Tdi and the same relay location is marked with 100 relay which means I can't borrow it for parts to test :(

[jon0881]

Ok so I can't wait to verify this. Quite proud of myself. I got some spare used relays and done a proper relay test first by testing full continuity.

Here is how I see the circuit causing the problem based on the info given.

T94 plug pin 69 ( black and gray) goes to t40 pin 6 then connection 3/86 on the relay. The other side of the relay providing the feed 4/85 goes to t40/15 (red and green). This then goes to t94 plug again on pin 92. This pin is shared with something else and is fed from Sb13 10a fuse.

I don't need to worry about the wires powering the ecu from the relay as those work when the relay is manually switched

[Crasher]

Yes, T94/69 at current track 72 to current track 40 at T40/6 (swartz/grau) is the earth command line, it is nice to know someone else likes reading VAG current flow diagrams. If there is continuity on that wire from J317/3 to T94/69 then it must be an internal ECU fault IF manually triggering the relay with an improvised earth fires up the ECU.

[jon0881]

Before i let them fix up a relay from the ignition feed to get round this i would like to see for meself;

1. Positive current to pin 4/85 at J371 when the ignition is on (this rules our fuse and power issues)
2. Swap out of the relay with another one i have bought and FULLY tested
3. Test continuety from pin 3 at J317 back to T94/69 at the ECU

Im fairly sure that this is a wiring issue. The replacement ECU performed in the exact same manner, granted it was a refurb unit but still. Ive been convinced from the start it was wiring or the relay. Are there any other earths going to the ECU to worry about in this case? I mean the ECU might not earth out the relay if it has no earth itself or have i misunderstood that one.

Its probably worth noting that this car was involved in a frontal motorcycle accident 4 years ago and in last august the gearbox was out on it. My uncles A3 had the gearbox out and after had limp mode issues which was down to a stretched wire when the gearbox was removed.

/Jon

[Crasher]

http://i222.photobucket.com/albums/dd20/Crasher1964/Type%2036%20CFFB%20engine%20current%20flow_zpsqqds cuk9.jpg (http://s222.photobucket.com/user/Crasher1964/media/Type%2036%20CFFB%20engine%20current%20flow_zpsqqds cuk9.jpg.html)

[jon0881]

The plot thickens......

The mechanic spent some more time on it today and I hope he was going through my print outs but it seems he stuck with his Bosch drawings. In any case I was told that the earth was switching now and that power on the other side was not there. Eh? So now there is a short wire from the 10a fuse in f13 going to the main relay. All codes have cleared and the cars fine. I'm itching to carry on with this myself to see if I can find the fault but I best leave it for a bit now.

I'm going to do the service myself instead now.

[Crasher]

Most people cannot get on with the VAG wiring diagrams, you have got it immediately, it took me years until it clicked. One of my friends who is an extremely skilled and intelligent mechanic (yes, they do exist!) is totally foxed by them. From what he found and using the VAG diagram it should be an immediate response to check for power at fuse SB13 as the feed from it barely leaves the engine bay electronics box before it divides off to the ECU and then straight back up to the electronics box, the wires literals goes out and almost straight back in as the use the same 40 pin connector. No power to J317 socket 4 but power out of fuse Sb13 means lift out the box and take a look at the junction which is called D78. Taking the box out is a bit of a pain, you have to disconnect all the SA cartridge fuse mounts and take off the bus bar, then wind out the T30 Torx and it lifts itself out of the connectors which you can then get to and and turn over.

[Crasher]

How are you getting on with this? I put the latest Elsie on my new work PC today and whilst looking for something else about 1.6 TDI EGR coolers I found a TPI2031123/1 which deals with a problem with the ECU relay in the engine E box where the grip of the connector inside the e box is insufficient and causes engine shut down, the solution is to replace the e box! It is the subject of a "workshop campaign" which also means a recall, reference 97Y6, ask your dealer. I hope you can read it, this is the cut down version!

http://i222.photobucket.com/albums/dd20/Crasher1964/TPI2031123-1_zpsslzd41z4.jpg (http://s222.photobucket.com/user/Crasher1964/media/TPI2031123-1_zpsslzd41z4.jpg.html)

[jon0881]

That's great thanks. I could zoom in and read it no problem. To be honest, I bought a power probe (not needed I know) and have just not dared touch it. The thought the of taking that box out and breaking something else is worrying. Especially as I've spent neat £500 for a short length of wire. I even fetched the 'tone and probe' kit from my desk at work to trace the wires. I will for sure call the dealer and ask about, again thanks so much for thinking of it!

i did however complete my service on it including the fuel filter which feast good for doing it.

[audi80quattro]

Hi,
Did you ever get this problem sorted?
I have a Passat TDI 140 2012 here with the same problem.
Most of the time the car works fine but sometimes it doesn't start and the glow lamp doesn't light up.
Tryed to change the ECU relay with no luck and of course it always work when im going to fix the car.'
Regards
Johan

[jon0881]

Hi

It's not really the same problem as mine was knackered all the time. The problem was a wiring issue with a positive feed to a relay under the fuse box. We bypassed the problem with a jumper wire and it's been fine since.

Jon

[Crasher]

Which relay did you change?

[audi80quattro]

Hi;
I canged the J317 relay in the engine compartment fuse box and I also took apart and checked the fuse box but cant see anything wrong there.

[Crasher]

Assuming it is a CFFB engine J317 is the terminal 30 relay, that is it takes in an unfused battery live feed equivalent to the typical plain red wire found anywhere in the car and the relay is powered by a permanent live feed from fuse 13 in the engine bay fuse board (SB) and commanded by an earth trigger from the ECU, the relay then provides a still unfused terminal 30 feed inside SB and powers fuses SB

10 Fuel metering and pressure regulating valves

14 Terminal 30 power to the ECU at pins T94 3, 5 and 6 on 2.5 mm² wire, so heavy duty!

16 EGR cooler changeover valve, boost control solenoid and EWP

23 Fuel pump relay command power

24 NOX sensor control unit, pre cat lambda probe

I can’t see this relay causing a starting problem

There is also relay J329 which is the terminal 15 which is commanded by the central electrics unit to turn on the ignition. The supply for this relay is also on terminal 30 BUT it does not come through J317, it is directly from the battery via fuse SB30 and this relay provides power to the dash side fuse box (SC) at fuses

1 Oil level sender
3 Crankcase heater for chilly climates
4 Stop/start light when fitted
10 Engine ECU ignition live signal, starter relay 2, Voltage supply relay 2,voltage stabiliser on stop/start cars, terminal 50 starter relay

So if it turns over when it won’t start, that relay should be OK.

[audi80quattro]

Hi,
Thanks for the reply, yes it is a CFFB engine and when the problem occurs the glow lamp is dark the tire pressure lamp lights up and the starter motor does not turn.
I changed the J317 relay again to a brand new one and for the moment the car is running.
I saw that this company in UK point out problems with the ECU.
VOLKSWAGEN PASSAT 2.0 TDI ECU (ENGINE MANAGEMENT) - Part No: 03L907309N / 0281016374 (http://www.ecutesting.com/catalogue/product/volkswagen_passat_ecu_engine_management_eem016374. html)

[Crasher]

That company is just down the road from where my wife works in Eastwood (D H Lawrence's birth place) and my stores chap used to work for him, with the local trade they are notorious for their work, I won't go anywhere near them.

[leswoollam]

I have exactly the same problem with my 2007Skoda Octavia VRS 2.0TDi. Relay J317 is fine; the fuse supplying it (F10) is fine and permanent voltage is getting to pin 85 of the relay. The wire running from pin 86 of the relay to the ECU connector tests perfectly for continuity. However, the ECU is not providing the relay with its earth, therefore relay J317 doesn't actuate.
I believe the ECU must have a separate switched supply to enable the earth to relay J317.
Does anyone have a circuit diagram for this car? That would really help me trace the problem.

[Crasher]

PM me the cars reg and your email.

[leswoollam]

I've sent you a PM. . . thanks!

[Crasher]

One point I can make without identifying which diagram is correct is that the J317 relay is the “Terminal 30 voltage supply relay, on the onboard power supply control unit” and is powered by fuse 15 in the dash side fuse board, the OPS unit is under the dash and the relay is mounted on the front panel at position B4 marked KL30 and it powers the interior, rear centre reading, front reading, luggage and glove compartment lights.

http://i222.photobucket.com/albums/dd20/Crasher1964/Golf5Onboardsupplycontrolunit.jpg (http://s222.photobucket.com/user/Crasher1964/media/Golf5Onboardsupplycontrolunit.jpg.html)

The engine ECU is powered via fuse 13 from relay J322 at position R1, both in the under bonnet fuse box and it splits into three feeds going to the ECU large plug at pins 3, 5 and the relay J322 is commanded by the ECU from pin 49 of the same plug. This feed line is called line 87 and it also feeds items such as the N75 valve and the lambda sensor heaters. The ECU is triggered by the line 50 relay which is called J682 and it is at position D2 under the dash below the onboard supply unit and it’s feed to the ECU goes through fuse 1 in the dash side fuse board and to the ECU, it is commanded by the onboard supply unit on instruction from the steering column ECU so I think it is J682 you are looking at.

[Crasher]

It was made on 5/11/2007 so it SHOULD be the latter wiring diagram but it is only 5 days into the change point.

[JamesBond007]

Hi!

I got a similar problem.
My Passat, 2012 2,0 tdi CFFB manual with start/stop, engine shuts down for time to time, ABS, ESP and engine warninglights is on.
When reading the error codes it is only one 01314 no communication with ECU. Could be that ECU is missing power perhaps.......

Any tip on trouble shooting this?
Greatful for all help I can get for this issue

Anyone having electronic scheme for this one?

Thanks in advance!

[Crasher]

Which controller are you seeing this fault code in, the CAN BUS?

[JamesBond007]

The controller for the ABS (anti break system)

[JamesBond007]

3465034651

34652
Posting a couple of pictures
Some more info
VOLKSWAGEN, VW 3C
WVWZZZ3CZCE167651
e1*2001/116*0307*31

[Crasher]

Contrary to what almost everyone thinks ABS stands for it is a rare example of a German language car technology acronym being widely adopted, mainly because it can be misinterpreted and mean the same thing, it actually stands for AntiBlockierSystem.

[Crasher]

Sorry, got interrupted for some household DIY interaction. The CAN BUS unit is susceptible to water damage but it is probaly the ABS ECU, can you fault code scan it?

[JamesBond007]

That makes sense, anti blockier system, describes more what the real functionally is.

[JamesBond007]

Yes with help from a friend.
The error code is 01314 No communication with ECU.

Problem is also that this issue is intermintent.
Right now the car is working fine.
It has happened 2 times.
First time I could start again after a few seconds and drove for 2-3 days.
Second time it stopped I could restart but dead again after couple of 100 meters. Started few times more but not for more that 50-100 meters.
Had to tow it back home. When finilay home it startaed again.
Don`t dare to use the car as it is now.

My amateur guess is that the ECU has no power when this happens. What do you think Crasher

[Crasher]

That's interesting you should say that as I am a bit confused by the Google translate interpretation of blockier as "blocking" because casting my memory back to 1978 when I read in "Autocar" and "The Motor" about the first Bosch ABS systems coming into the UK on big Mercs and that OTHER German brand, they translated blockier as "skidding" but Google translates it as "Blocking" which doesn't make sense to an English chap like me, it almost gives the impression of being "anti stopping system" which is the opposite of what it is, so does blockier also mean skidding or slipping?

[JamesBond007]

For me as swedish anti blocking is, if I translate, to prevent breaks to lock itself (sorry for my english. Hopfully you undertsand)

[Crasher]

Your English is better than my Swedish! ;)

[JamesBond007]

Posting this again if you missed this Crasher

Yes with help from a friend.
The error code reported in ABS is 01314 No communication with ECU.
No error codes in ECU.

Problem is also that this issue is intermintent.
Right now the car is working fine.
It has happened 2 times.
First time I could start again after a few seconds and drove for 2-3 days.
Second time it stopped I could restart but dead again after couple of 100 meters. Started few times more but not for more that 50-100 meters.
Had to tow it back home. When finilay home it started again.
Don`t dare to use the car as it is now.

My amateur guess is that the ECU has no power when this happens.

[Crasher]

Something like that can be awful to track down, firstly I would check the engine and ABS ECU plugs for water damage but after that you would have to strip the wiring out to inspect it for damage which is laborious and with no guarantee of success.

[JamesBond007]

Hi!

Do you, Crasher, think you have electrical scheme for this one?

[Crasher]

Yes, I can send it to your email, Private Message me the address you would like me to use.

[JamesBond007]

Don`t now if you recieved PM.

I saw this:
Note: Until your post count is 15 you will be able to send PMs to Staff only.

[Crasher]

Yes it (they) is (are) there but I won't open it (them) until tomorrow as otherwise I will forget...:confused:

[JamesBond007]

Thank you Crasher for the email.
Now the interesting fault tracing will begin.....

Probebly not until next week. Going skiing until sunday. Not by my car :(

[JamesBond007]

Hi Crasher!

Yesterday we checked car. Starting working fine. We read and cleared error codes.
This morning I started the diesel heater by remote and when I tried to start it wouldn`t start.
Engine, ABS, and ESP lamp is yellow.
We can`t read error codes now, no communication. Using Auto-com as communication program.

[JamesBond007]

We tested the auto-com on other car no problem so the comunication is only on my car.
Any ide?

Checked fuse F7, F15 both ok
Also checked F4, F13 also ok
Now all fuses checked in engine bay and left side "door" panel.

[JamesBond007]

Total failure of ECU would that cause no comminication?

[JamesBond007]

Picture of the dashboard when the car won`t start
34669

[JamesBond007]

3474334744
ECU before and after restoration. The car now working fine again.

[Crasher]

What happened to that? It looks like it has been in a fire?

[--jp]

Apologies to jump on such an old thread but seems prudent to keep all this info together in case anyone is unfortunate enough to end up here!

I've followed this thread and thanks to all input I've managed to get my friends golf (2.0 tdi 140 mk6 59plate) running. All be it with the main 100 relay on the sb board hot wired. It seems at its not switching the earth or supplying 12v to the low power side. I've checked everything I can and cannot seem to find anything wrong besides that.

Symptoms were cutting out. Then restarted for less than 2 minutes and then dead. Cranking but no prime etc and no communication with the ecu via vag com. Manually closing the relay on SB would allow engine start and vagcom connection.

Any ideas on what next? I can jumper the wires obviously but I'm struggling to find a switched live which doesn't disappear on cranking?

Thanks for any input!

[Crasher]

Can you private message me the cars reg number?

[--jp]

I haven't got enough post count. How about this
LO59

[--jp]

Obk

[Crasher]

A Golf 6 type 5K1 473 with a CFFB engine, LTE DSG gearbox, built 14-01-2010 and a 2010 model in A7W Reflex silver. This car has the "E-box low" SB fuse/relay carrier with positions for two relays A1 and A2. A1 is the J317 terminal 30 relay (i.e. main power) and A2 has a metal bridge across the power terminals.

According to ElsaWin the relay in position A2 (the J317) should have the control group number 458 printed on top and according to FI Suggestion on ETKA it should now (or replaced by) 644 and VAG part number 4H0 951 253 which is green and £20.68 from VAG dealers/TPS. A control group 100 relay is a 7M0 951 253 A and is used in position A2 on petrol engined models, however I took this picture of a 2009 Golf 6 ebox with the 2 Litre CRTDI engine

https://live.staticflickr.com/1833/43190298644_900ece6b91_o.jpg (https://flic.kr/p/28Nzz4s)

The J317 relay is activated by the engine ECU at pin 86 with a negative signal and at pin 85 it is provided with power from fuse SB10

The J317 provides power to fuses SB 13, 22, 15, 21, 24, 23 and 14

[--jp]

Spot on all of that. It too had a 100 marked relay.

No earth trigger from ecu. I've had a look at the harness and doesn't seem to have any damage. Could this be a sign the ecu is headed for the bin? I'll check sb10 again.

Any solutions better than rerouting earth trigger and feed to the battery?

I was hoping to find a switched live etc but as you know the ecu disconnects the obvious ones on cranking

[Crasher]

You need to access the ECU (which is a pain), release the chastity belt and disconnect the large 94 pin plug and test the continuity of the tiny 0.35mm CSA black/grey wire at point 69 (T94/69) to the 86 socket on the SB plate.

https://live.staticflickr.com/7816/47490644452_41217c1b5f_o.jpg (https://flic.kr/p/2fmzY3G)

I did a 2010 CAVD 1.4 TSI today and this is the SB plate with 100 relays, the CFFB should have the 458/644 relay

https://live.staticflickr.com/7913/46819764784_47af3a5358_o.jpg (https://flic.kr/p/2ekiwTS)

This car has, I suspect, a faulty ECU in that it is not driving the N249 valve correctly and it has been "got at", no longer virgin territory.... if you know what I mean....

[VitalSpark74]

Thanks everyone for this thread.
I've just repaired my 2010 a3 with the help of this thread. The grey/black relay control wire was broken about 6" down the SB harness. Mine was chaffing ever so slightly against the battery tray.
Air filter housing, airbox, battery, battery tray, SB fusebox split to gain access.
Soldered the connection back together with heatshrink to protect.
About 1-2 hours work depending on working speed.
Autoelec by trade so know how these kind of things can stump you and be time consuming.
Strange thing was I had comms with engine ecu but diag snapshot showed no terminal 30 power but in effect this should be terminal 15 ignition supply.
Screenshot_20191004-150250__01 | Mike Ure | Flickr (https://flic.kr/p/2hrYoJX)
IMG_20191004_134632 | Mike Ure | Flickr (https://flic.kr/p/2hs22j4)
IMG_20191004_134609 | Mike Ure | Flickr (https://flic.kr/p/2hs22i2)
IMG_20191004_134621__01 | Mike Ure | Flickr (https://flic.kr/p/2hs29Ry)
https://flic.kr/p/2hs29QX

[Lainy00000]

By any chance did your fans come on full speed with ignition on after couple seconds ? Glow light stays on no comms with ecu? I was getting comms then I didn’t , had a motor flap fault code so changed that and also a ecu short to ground fault now no comms at all to engine ecu. Same when checked with multimeter I get power to relay etc but no switched signal from ecu . Sorry for bringing up an old post just it all seems relevant and thought best kept in one place as was previously stated

[Crasher]

The fans coming on shows the controller knows or thinks the engine is running but it is not receiving a temperature signal from the ECU so it assumes the car is overheating and puts the fans on at full speed; it is very annoying when working on one with an ECU feed problem so I pull the fuse. What car do you have?

[Lainy00000]

Hi crasher thanks for replying, it’s a 2008 Audi A3 se with a 1.9 bxe engine , everything in this thread seems to be exactly the same as the problems I’m having and have checked everything now apart from the black and grey wire which I’m on today as just got ecu out last nite due to them anti tamper screws taken the mick haha. I’m not great with electrics but managing to do everything else mentioned so far . When I did get a connection the fault was manifold flap or motor no signal and then was no communication to ecu / short to ground. . Thanks

[Lainy00000]

Also forgot to mention it connects to all other controllers through vcds just not the ecu one now. If I removed sb24 fuse and cycled ignition off and on a couple times I could then hear the pump kick on and knew car would start but then that stopped working too . Also swapped over the manifold swirl flap motor and no more code so just the ecu short to ground.

[Lainy00000]

So turned out mines was an ecu issue it stopped sending signal, replaced ecu all working again but see what you mean about them grey and black wires although mines was in pin 67 not 69 of the t94 plug, pin 69 had a yellow and purple wire in it also had two grey and black wires

[DieselMonster]

Awesome thread, Ive PM'd you Lainy

[Lainy00000]

I have pmd you back not sure if it’s gone through as I’m fairly new to the group , it’s not shown in my sent messages but if you don’t get it I can try send my email somehow or if you want to send details over I will try help

[raki]

After reading this thread I thought it's the right place for my issue.
Passat B7 2.0 TDI CFGB Start/stop 2011
It started last year in January.
Coming to the car, trying to start but nothing, loads of faults lights up, parking sensors and radio not functional, fan in engine bay turns on. I tried connecting wires from another car and it has started but only for few seconds and it stopped again.
Changed battery for new, no help.
My friend suggested it could be water damaged ECU so we took it out and send to ECU testing. It came back without any faults so fitted back to the car and it worked flawlessly for a year.
Few days back I went to work and after 6h it wouldn't start. Same problem. Unplugged battery for 5 mins, tried and started but only for few seconds again.
Took ECU out and left it on radiator overnight, next day worked without problems but few days later same happened. Thinking it could be something with moisture I have sent it to ECU guys again but it has passed all their tests... So waiting for it to come back to me. Looking at the pattern I suspect it will start and work but not sure for how long lol
When it wouldn't start, computer could not detect VIN on its own but read all the codes but did not manage to clear them.
When it was fitted back after night it read VIN without problems.

Does anyone have any suggestions where and what to look for?

[Lainy00000]

Do you by any chance have a note of the codes that you got coming up on diagnostic? Is all the dash lights coming on and fan etc again too same as the first time this happened to you? My ecu had failed on me after checking almost everything I could as had similar issues but eventually swapped for another ecu and car ran great, decided to look in to my old ecu and find that the ecu itself was fine but had somehow corrupted files on it, restored all original files on it and the ecu is fine again. I read the other day a procedure that can be done on Passat to reset ecu and throttle body etc I’ll post the link maybe worth a try too. Here’s the link I had it saved it’s for a b5 but may still work

VW Passat B5 Guides: Passat B5 Throttle Body & ECU Reset (Battery Replacement) (http://danzuc.blogspot.com/2010/11/passat-b5-throttle-body-ecu-reset.html)

[raki]

Got the ECU back from ECU Testing yesterday. They could not find any fault with it.
I have fitted it back in today. So far so good but I think it's not over yet ;)

[TKPeters]

Same Issue, No Comms with ECU, Fans on full
Seems to have power to all the fuses & relays
Will remove the Anti-Tamper bolts to check the ECU
Is the ECU / Internal Moisture usually the fault?



Monday,01,March,2021,15:12:35:26539
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 20.12.0.0 (x64) HEX-NET CB: 0.4529.4
Data version: 20201124 DS322.0
Ross-Tech: Home (www.Ross-Tech.com)

VIN: WVWZZZ3CZBP348334 License Plate: *******
Mileage: 233810km-145282mi Repair Order:


Chassis Type: 3C-VW46 (7N0)
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 72

VIN: WVWZZZ3CZBP348334 Mileage: 233810km-145282miles

01-Engine -- Status: Cannot be reached 1100
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: Malfunction 0010
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
53-Parking Brake -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
72-Door, Rear Right -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine
Cannot be reached

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 M HW: 3AA 614 109 M
Component: J104 C2 450M V4A1 0005
Revision: --H07--- Serial number: 00000004061796
Coding: 0002992
Shop #: WSC 00028 028 00001
VCID: B73E7F2AC62AAF3C72-80E2

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 22
Reset counter: 161
Mileage: 233819 km
Time Indication: 0
Date: 2015.06.24
Time: 14:00:33

Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 11.25 V
Bin. Bits: 00011111
Count: 217
Hex Value: 0x0000

00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.06.24
Time: 14:44:42

Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 7.25 V
Bin. Bits: 00011111
Count: 115
Hex Value: 0x0000


-------------------------------------------------------------------------------

[Crasher]

The battery is flat, in the ABS 2nd code it shows 7.25v.

[TKPeters]

Battery has been replaced, as it was the original battery & the running fans keep flattening it
ECU removed & I have continuity on pin 69

Rescanned with VCDS 21.3



Tuesday,02,March,2021,11:48:43:26539
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 21.3.0.0 (x64) HEX-NET CB: 0.4543.4
Data version: 20210226 DS325.0
www.Ross-Tech.com (http://www.Ross-Tech.com)


VIN: WVWZZZ3CZBP348334 License Plate: *****
Mileage: 233810km-145282mi Repair Order:



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 3C-VW46 (7N0)
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 72

VIN: WVWZZZ3CZBP348334 Mileage: 233810km-145282miles

01-Engine -- Status: Cannot be reached 1100
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine
Cannot be reached

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 M HW: 3AA 614 109 M
Component: J104 C2 450M V4A1 0005
Revision: --H07--- Serial number: 00000004061796
Coding: 0002992
Shop #: WSC 00028 028 00001
VCID: B73E7F2AC62AAF33B2-80E2

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 95
Reset counter: 161
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 00:38:03

Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 11.25 V
Bin. Bits: 00011111
Count: 217
Hex Value: 0x0000


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 5K0 907 044 DT HW: 5K0 907 044 DT
Component: Climatronic H17 1010
Revision: 00003001
Coding: 0000000003
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW36.rod
VCID: 804CD4F61B64288B43-80D4

2 Faults Found:
13701376 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Motorsteuergerät - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 9
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.02
Time: 00:38:03

9481748 - High Pressure Sensor
B10AE 14 [008] - Open or Short to Ground
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.02
Time: 00:43:49


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 3AA-937-087.clb
Part No SW: 3AA 937 087 A HW: 3AA 937 087 A
Component: BCM PQ47 H 413 0452
Revision: BB413001
Coding: 000000000000000000180080140081E443516488406C816064 80C7200041
Shop #: WSC 00028 028 00001
VCID: B83C7C160B34A04BBB-80EC

Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 09031 26 0612
Coding: 00B795

Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 120411 05 54 0403
Coding: 0330ED

2 Faults Found:
00526 - Brake Light Switch (F)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 3
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 19:34:42

Freeze Frame:
Term 15 Off
Voltage: 10.70 V
OFF
ON
OFF
OFF
OFF

01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 6
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 19:33:32

Freeze Frame:
Term 15 On
Voltage: 10.70 V
ON
ON
ON
OFF
OFF


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 HW: 7N0 919 475
Component: PARKHILFE 8K H04 0009
Revision: -------- Serial number: 28291107749682
Coding: 108001
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_EPHVA18VW47X0000 001003
ROD: EV_EPHVA18VW47X0000.rod
VCID: FCB4A006778C4C6B1F-80A8

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 R HW: 5N0 959 655 R
Component: J234__102 VW10 HI 1918
Revision: 22014000 Serial number: 003K0P6A0TT-
Coding: 0012338
Shop #: WSC 00028 028 00001
VCID: CCD430C6AFAC3CEBEF-8098

Subsystem 1 - Serial number: 6332MTS625650741

Subsystem 2 - Serial number: 6342MTS636660751

Subsystem 3 - Serial number: 6351HTS6N43CS9KR

Subsystem 4 - Serial number: 6361HTS6CMRIS9KR

Subsystem 5 - Serial number: 00000000000000000

Subsystem 6 - Serial number: 00000000000000000

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C5 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 014 0140
Revision: FF010040 Serial number: 20110408101598
Coding: 1182250000
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: F2A88E3E25C80A1B45-80A6

Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H06 0022
Coding: E20000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 970 A HW: 3AA 920 970 A
Component: KOMBI H20 0420
Serial number: 00000000000000
Coding: 460F00
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04089
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod
VCID: B12A4132E04E7103FC-80E4

1 Fault Found:
12648448 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Steuergerät für Motor: keine Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.02
Time: 00:38:02


-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 G HW: 1K0 907 951
Component: J533 Gateway H41 1614
Revision: H41 Serial number: 080411F1001509
Coding: 461007
Shop #: WSC 00028 028 00001
VCID: B4244826175C442B97-80E0

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 00:38:03


-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 HW: 3AA 959 433
Component: IMMO 043 0399
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: F6A0B22E81A0163B69-80A2

Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 D HW: 5N0 035 342 D
Component: SG EXT.PLAYER H13 0150
Revision: A1001003 Serial number: 7669743207
Coding: 020000
Shop #: WSC 00028 028 00001
VCID: A81CAC56DB9430CB2B-80FC

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C0 035 279 HW: 3C0 035 279
Component: RNS315 H05 0010
Serial number: VWZAZ2L3320713
Coding: 040004010400000000011000
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_RNS315VWEUV1UDS A01005
ROD: EV_RNS315VWEUV1UDS.rod
VCID: E08CF476FB24888B23-80B4

6 Faults Found:
1048597 - Front Left Treble Speaker
B1061 13 [009] - Open Circuit
[tweeter front left open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.02
Time: 19:41:22

1048598 - Front Right Treble Speaker
B1064 13 [009] - Open Circuit
[tweeter front right open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.02
Time: 19:41:22

1048599 - Rear Left Treble Speaker
B1066 13 [009] - Open Circuit
[tweeter rear left open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.02
Time: 19:41:22

1048600 - Rear Right Treble Speaker
B1068 13 [009] - Open Circuit
[tweeter rear right open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.02
Time: 19:41:22

1048661 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[CAN TO park distance control]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.02
Time: 00:43:48

1048658 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[CAN TO speed signal]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.02
Time: 00:43:48


-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 0530
Revision: 12110009 Serial number: 0002608904
Coding: 0202B7
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: B522752214265D23A0-80E0

Slave Driver:
Subsystem 1 - Part No SW: 3C0 959 704 HW: 3C0 959 794 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 004 0408
Serial number: 00000002057477
Coding: 000290

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 M
Component: EPS_ZFLS Kl. 195 3201
Revision: 00H20000
Shop #: WSC 00028 028 00001
VCID: B4244826D75C442B97-80E0

2 Faults Found:
03803 - Steering Angle Sensor for Steering Aid
000 - - - MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 00:38:02

Freeze Frame:
Battery Volts: 11.5 V
DU
Temperature: 15.0°C
Count: 2
Steering Angle: 0.00°
Count: 1
SteerAng n.Init

01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 00:38:02

Freeze Frame:
Voltage: 11.50 V
DU
Temperature: 15.0°C
RPM: 1498 /min
Speed: 0.0 km/h
Speed: 0.0 km/h
Count: 0


-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 HW: 3AA 959 433
Component: KSG PQ47 ELV 043 0631
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 01910A0002860E76300494157C085FCE105C01
Shop #: WSC 18798 014 67328
VCID: F6A0B22E81A0163B69-80A2

Subsystem 1 - Part No: 1K8 951 605 B
Component: LIN BACKUP HORN H11 9005

Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611

Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611

2 Faults Found:
00625 - Vehicle Speed Signal
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 4
Fault Frequency: 3
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 00:43:43

01321 - Control Module for Airbags (J234)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 4
Fault Frequency: 2
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.24
Time: 00:43:45


-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 1K0 907 951
Component: EZE_2 H41 1614
Revision: H41 Serial number: 080411F1001509
Coding: 00000008
Shop #: WSC 00028 028 00001
VCID: EFAE874A3EFA27F3AA-80BA

Subsystem 1 - Part No SW: 3AA 919 204 A HW: 3AA 919 204 A
Component: Analoguhr 004 0003

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0530
Revision: 14110009 Serial number: 0002615956
Coding: 0202B6
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: B620722E0920563BA9-80E2

Slave Passenger:
Subsystem 1 - Part No SW: 3C0 959 703 HW: 3C0 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0408
Serial number: 00000002069667
Coding: 000290

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 E HW: 3AA 907 801 E
Component: J540 EPB4 VW-55183 0007
Revision: H18 Serial number: 00000000275996
Coding: 0022067
Shop #: WSC 00028 028 00001
VCID: B3264B3AD25243138E-80E6

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 85
Reset counter: 161
Mileage: 233819 km
Time Indication: 0
Date: 2015.06.21
Time: 11:24:41

Freeze Frame:
Voltage: 11.70 V
Count: 71
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010


-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 1K0 907 951
Component: Batt.regelung H41 1614
Serial number: 080411F1001509
Coding: 030B185A
Shop #: WSC 00028 028 00001
VCID: F1AA813228CE3103BC-80A4

Subsystem 1 - Part No SW: 1K0 915 181 F HW: 1K0 915 181 A
Component: J367-BDM H07 0150
Serial number: 00000000009370130638

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 B HW: 3AA 907 273 B
Component: RDKBERU30 H08 0008
Serial number: 10000000029158
ASAM Dataset: EV_RDKBERU30 003010
ROD: EV_RDKBERU30_003.rod
VCID: B3264B3A1A5243138E-80E6

1 Fault Found:
12656671 - No Communication with Diagnostic Gateway
U0146 00 [008] - -
[Gateway keine CAN Kommunikation]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.02
Time: 00:43:24


End----(Elapsed Time: 01:49, VBatt start/end: 10.5V/10.4V. VIgn 10.5V)-----

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Address 19: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Address 09: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Address 03: DTCs cleared

[philipharmes]

On your latest scan it still shows low voltages " End----(Elapsed Time: 01:49, VBatt start/end: 10.5V/10.4V. VIgn 10.5V)----- "

Can't you disconnect the fans until you get the engine running & avoid flattening the battery & give the battery a good charge.

The fact that there is no communication with the engine module 01 could be that it is missing one or more +12v supplies, or just due to the low voltage it's getting from the battery.
There are several +12v supplies it needs to function, but you will need a wiring diagram to check which pins on the ECU to check.

[TKPeters]

I'm aware of the voltage issues [The Passat is a long way from any power source to charge the battery whilst working on the car],
This does not negate that the ECU is dead / not communicating.
I have the ERWIN Diagrams & I've checked the power lines 3,5,6 & continuity with Pin 69.

37817
37818

[TKPeters]

Just to update the thread.
The 2012 Passat's ECU was sent to ECUTesting & it was faulty, turnaround within a week [During Lockdown 3.0] & the car is running again after being sat for 3 months.
Thanks for the advice & so glad it wasn't a broken wire.

Battery fully Charged & new scan via VCDS 21.3
Lots of fault codes, from the faulty ECU & all cleared & running fine.




VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 21.3.0.0 (x64) HEX-NET CB: 0.4543.4
Data version: 20210226 DS325.0
www.Ross-Tech.com (http://www.Ross-Tech.com)

VIN: WVWZZZ3CZBP348334 License Plate: *******
Mileage: 233810km-145282mi Repair Order:



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 3C-VW46 (7N0)
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 72

VIN: WVWZZZ3CZBP348334 Mileage: 233810km-145282miles

01-Engine -- Status: Malfunction 1010
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: Malfunction 0010
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFFB) Labels:. 03L-906-018-CFF.clb
Part No SW: 03L 906 018 BF HW: 03L 907 309 N
Component: R4 2.0l TDI H24 9978
Revision: 47H24--- Serial number: VWZCZ000000000
Coding: 00190012042501080000
Shop #: WSC 24977 002 1048576
ASAM Dataset: EV_ECM20TDI01103L906018BF 003008
ROD: EV_ECM20TDI01103L906018BF.rod
VCID: EFAE874A36FA27F3AA-80BA

8 Faults Found:
5463 - Starter Control; Returned Message
P3052 00 [036] - 50 Short to Plus
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 1262.50 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 67 °C
Intake air temperature: 64 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.700 V
Unlearning counter according OBD: 40
Engine control module reset status-Bits 0-7: 0
Engine control module reset status-Bits 0-7: 0
Limitation: torque: 0.0 Nm
Limitation: accelerator pedal: 41.1 Nm
Cruise Control System (CCS): status-Bits 0-7: 201
Accelerator pedal travel: 11.40 %
Engine torque: -500.0 Nm
Generator: load signal: 30.00 %

4967 - Fuel Temp. Sensor A (G81)
P0183 00 [036] - Open or Short to Plus
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 1207.50 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 67 °C
Intake air temperature: 64 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.700 V
Unlearning counter according OBD: 40
Fuel consumption: 0.00 l/h
Engine oil temperature: 79.3 °C
Oil warning threshold: 14.660 mm
Control Module temperature: 16.1 °C
Oil fill level: 0.000 mm
Outside temperature: -0.0 °C
Fuel temperature: -40.0 °C

5134 - Valve for Fuel Metering (N290)
P0091 00 [036] - Short to Ground
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 °C
Intake air temperature: 64 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Engine status: COENG_FINISH
Engine status-Test_Program_Co Eng st COMPU VERB UBYTE: 5

5281 - Mass Air Flow Sensor (G70)
P0101 00 [036] - Implausible Signal
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 1207.50 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 67 °C
Intake air temperature: 64 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.700 V
Unlearning counter according OBD: 40
Throttle valve adapter: specified value: 100.00 %
EGR Solen.val.: actual value: 100.56 %
Charge air pressure: specified value: 1030 hPa
Charge air pressure actuator: acknowledgment: 91.03 %
Air mass: specified value: 354.4 mg/stroke
Air mass: actual value (mg/stroke): 0.0 mg/stroke

10092 - Neutral Gear Sensor
P15A0 00 [036] - Electrical Malfunction
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 1262.50 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 67 °C
Intake air temperature: 64 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.700 V
Unlearning counter according OBD: 40
Neutral position sensor: current transmission angle: 20.00 °
Neutral position sensor: adapted transmission angle: 0.00 °
Transmission neutral position sensor voltage: 0 mV
selected gear-Bits 0-7: 0

5523 - Engine Start Blocked by Immobilizer
P1570 00 [038] - -
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 1262.50 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 67 °C
Intake air temperature: 64 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.700 V
Unlearning counter according OBD: 40
Immobilizer snapshot A-Sia Error Snap A: 14 80 09
Immobilizer snapshot B-Sia Error Snap B: 02 00 00

9123 - Throttle Actuator Control System
P2112 00 [036] - Stuck Closed
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 60 °C
Intake air temperature: 63 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Air mass: actual value (mg/stroke): 0.0 mg/stroke
Throttle valve adapter: specified value: 0.00 %
Throttle valve adapter: actual value: 81.95 %
Throttle valve adapter: offset closed: -1.14 %
Throttle valve adapter: status-Bits 0-7: 0
Throttle valve adapter: status-Bits 0-7: 55
Throttle valve adapter: status-Bits 0-7: 43
Throttle valve adapter: status-Bits 0-7: 4
Throttle valve adapter: uncond voltage actual value: 3573.4 mV

9124 - Throttle Actuator Control System
P2111 00 [036] - Stuck Open
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 51 °C
Intake air temperature: 63 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Air mass: actual value (mg/stroke): 0.0 mg/stroke
Throttle valve adapter: specified value: 100.00 %
Throttle valve adapter: actual value: 88.31 %
Throttle valve adapter: offset closed: -1.14 %
Throttle valve adapter: status-Bits 0-7: 0
Throttle valve adapter: status-Bits 0-7: 55
Throttle valve adapter: status-Bits 0-7: 40
Throttle valve adapter: status-Bits 0-7: 4
Throttle valve adapter: uncond voltage actual value: 3809.0 mV

Readiness: 0 0 0 0 1

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 M HW: 3AA 614 109 M
Component: J104 C2 450M V4A1 0005
Revision: --H07--- Serial number: 00000004061796
Coding: 0002992
Shop #: WSC 00028 028 00001
VCID: B73E7F2AC62AAF33B2-80E2

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 3
Fault Frequency: 13
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.08.03
Time: 00:03:29

Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 9.75 V
Bin. Bits: 00011111
Count: 217
Hex Value: 0x0000


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 5K0 907 044 DT HW: 5K0 907 044 DT
Component: Climatronic H17 1010
Revision: 00003001
Coding: 0000000003
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW46.rod
VCID: 804CD4F61B64288B43-80D4

1 Fault Found:
13701376 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[Motorsteuergerät - kein Signal/Kommunikation]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 4
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.12
Time: 19:44:07


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 3AA-937-087.clb
Part No SW: 3AA 937 087 A HW: 3AA 937 087 A
Component: BCM PQ47 H 413 BCM PQ47 H 413 04520452
Revision: BB413001
Coding: 000000000000000000180080140081E443516488406C816064 80C7200041
Shop #: WSC 00028 028 00001
VCID: B83C7C160B34A04BBB-80EC

Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 09031 26 0612
Coding: 00B795

Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 120411 05
Coding: 0330ED

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 HW: 7N0 919 475
Component: PARKHILFE 8K H04 0009
Revision: -------- Serial number: 28291107749682
Coding: 108001
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_EPHVA18VW47X0000 001003
ROD: EV_EPHVA18VW47X0000.rod
VCID: FCB4A006778C4C6B1F-80A8

1 Fault Found:
13893632 - Function Restricted due to Insufficient Voltage
U1400 00 [008] - -
[Funktionseinschränkung durch Unterspannung - unterer Grenzwert unterschritten]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.12
Time: 00:04:34


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 R HW: 5N0 959 655 R
Component: J234__102 VW10 HI 1918
Revision: 22014000 Serial number: 003K0P6A0TT-
Coding: 0012338
Shop #: WSC 00028 028 00001
VCID: CCD430C6AFAC3CEBEF-8098

Subsystem 1 - Serial number: 6332MTS625650741

Subsystem 2 - Serial number: 6342MTS636660751

Subsystem 3 - Serial number: 6351HTS6N43CS9KR

Subsystem 4 - Serial number: 6361HTS6CMRIS9KR

Subsystem 5 - Serial number: 00000000000000000

Subsystem 6 - Serial number: 00000000000000000

1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 3
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.08.03
Time: 00:04:49


-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C5 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 014 0140
Revision: FF010040 Serial number: 20110408101598
Coding: 1182250000
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: F2A88E3E25C80A1B45-80A6

Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H06 0022
Coding: E20000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 970 A HW: 3AA 920 970 A
Component: KOMBI H20 0420
Serial number: 00000000000000
Coding: 460F00
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04089
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod
VCID: B12A4132E04E7103FC-80E4

2 Faults Found:
12648448 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[Steuergerät für Motor: keine Kommunikation]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.12
Time: 00:02:24

13638912 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[Steuergerät für Lenkhilfe: keine Kommunikation]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.12
Time: 00:09:23


-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 G HW: 1K0 907 951
Component: J533 Gateway H41 1614
Revision: H41 Serial number: 080411F1001509
Coding: 461007
Shop #: WSC 00028 028 00001
VCID: B4244826175C442B97-80E0

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.08.03
Time: 00:00:21


-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 HW: 3AA 959 433
Component: IMMO 043 0399
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: F6A0B22E81A0163B69-80A2

Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380

1 Fault Found:
02861 - Electronic Steering Column Lock Check Sum Error
014 - Defective - Intermittent
Freeze Frame:
Fault Status: 00111110
Fault Priority: 4
Fault Frequency: 1
Reset counter: 201
Mileage: 0 km
Time Indication: 0


-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 D HW: 5N0 035 342 D
Component: SG EXT.PLAYER H13 0150
Revision: A1001003 Serial number: 7669743207
Coding: 020000
Shop #: WSC 00028 028 00001
VCID: A81CAC56DB9430CB2B-80FC

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C0 035 279 HW: 3C0 035 279
Component: RNS315 H05 0010
Serial number: VWZAZ2L3320713
Coding: 040004010400000000011000
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_RNS315VWEUV1UDS A01005
ROD: EV_RNS315VWEUV1UDS.rod
VCID: E08CF476FB24888B23-80B4

5 Faults Found:
1048580 - Function Restricted due to Insufficient Voltage
U1400 00 [008] - -
[restriction due to undervoltage]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Date: 2021.03.12
Time: 00:04:34

1048597 - Front Left Treble Speaker
B1061 13 [009] - Open Circuit
[tweeter front left open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.12
Time: 19:44:10

1048598 - Front Right Treble Speaker
B1064 13 [009] - Open Circuit
[tweeter front right open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.12
Time: 19:44:10

1048599 - Rear Left Treble Speaker
B1066 13 [009] - Open Circuit
[tweeter rear left open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.12
Time: 19:44:10

1048600 - Rear Right Treble Speaker
B1068 13 [009] - Open Circuit
[tweeter rear right open load]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 161
Mileage: 233819 km
Date: 2021.03.12
Time: 19:44:10


-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 0530
Revision: 12110009 Serial number: 0002608904
Coding: 0202B7
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: B522752214265D23A0-80E0

Slave Driver:
Subsystem 1 - Part No SW: 3C0 959 704 HW: 3C0 959 794 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 004 0408
Serial number: 00000002057477
Coding: 000290

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 M
Component: EPS_ZFLS Kl. 195 3201
Revision: 00H20000
Shop #: WSC 00028 028 00001
VCID: B4244826D75C442B97-80E0

3 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.08.03
Time: 19:44:06

Freeze Frame:
Voltage: 10.38 V
DU
Temperature: 14.0°C
RPM: 1498 /min
Speed: 0.0 km/h
Speed: 0.0 km/h
Count: 0

00750 - Warning Lamp
013 - Check DTC Memory - Intermittent
Freeze Frame:
Fault Status: 00101101
Fault Priority: 2
Fault Frequency: 1
Reset counter: 40
Time Indication: 0

Freeze Frame:
Voltage: 10.25 V
PD
Temperature: 12.0°C
RPM: 1498 /min
Speed: 0.0 km/h
Speed: 0.0 km/h
Count: 0

02391 - Terminal 30 Reference
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 3
Fault Frequency: 1
Reset counter: 255
Time Indication: 0

Freeze Frame:
Voltage: 12.50 V
PD
Temperature: 6.0°C
Speed: 50.0 km/h
Torque: 0.0 Nm
Torque: 0.000 Nm
Term 15 On


-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 HW: 3AA 959 433
Component: KSG PQ47 ELV 043 0631
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 01910A0002860E76300494157C085FCE105C01
Shop #: WSC 18798 014 67328
VCID: F6A0B22E81A0163B69-80A2

Subsystem 1 - Part No: 1K8 951 605 B
Component: LIN BACKUP HORN H11 9005

Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611

Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611

1 Fault Found:
01134 - Alarm Horn (H12)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 4
Fault Frequency: 4
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.08.03
Time: 00:00:13


-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 1K0 907 951
Component: EZE_2 H41 1614
Revision: H41 Serial number: 080411F1001509
Coding: 00000008
Shop #: WSC 00028 028 00001
VCID: EFAE874A3EFA27F3AA-80BA

Subsystem 1 - Part No SW: 3AA 919 204 A HW: 3AA 919 204 A
Component: Analoguhr 004 0003

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0530
Revision: 14110009 Serial number: 0002615956
Coding: 0202B6
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: B620722E0920563BA9-80E2

Slave Passenger:
Subsystem 1 - Part No SW: 3C0 959 703 HW: 3C0 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0408
Serial number: 00000002069667
Coding: 000290

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 E HW: 3AA 907 801 E
Component: J540 EPB4 VW-55183 0007
Revision: H18 Serial number: 00000000275996
Coding: 0022067
Shop #: WSC 00028 028 00001
VCID: B3264B3AD25243138E-80E6

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 107
Reset counter: 201
Mileage: 233819 km
Time Indication: 0
Date: 2015.07.01
Time: 11:24:41

Freeze Frame:
Voltage: 11.70 V
Count: 71
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010

03182 - Clutch Position Sensor (G476)
010 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 2
Fault Frequency: 2
Reset counter: 201
Time Indication: 0

Freeze Frame:
Voltage: 11.10 V
Count: 55
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010


-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 1K0 907 951
Component: Batt.regelung H41 1614
Serial number: 080411F1001509
Coding: 030B185A
Shop #: WSC 00028 028 00001
VCID: F1AA813228CE3103BC-80A4

Subsystem 1 - Part No SW: 1K0 915 181 F HW: 1K0 915 181 A
Component: J367-BDM H07 0150
Serial number: 00000000009370130638

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 B HW: 3AA 907 273 B
Component: RDKBERU30 H08 0008
Serial number: 10000000029158
ASAM Dataset: EV_RDKBERU30 003010
ROD: EV_RDKBERU30_003.rod
VCID: B3264B3A1A5243138E-80E6

No fault code found.

End----------(Elapsed Time: 03:20, VBatt start/end: 14.7V/14.8V)-----------




--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Gateway Installation List: 7N0 907 530 G

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 3C-VW46 (7N0)
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 72

VIN: WVWZZZ3CZBP348334 Mileage: 233810km-145282miles

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFFB) Labels:. 03L-906-018-CFF.clb
Part No SW: 03L 906 018 BF HW: 03L 907 309 N
Component: R4 2.0l TDI H24 9978
Revision: 47H24--- Serial number: VWZCZ000000000
Coding: 00190012042501080000
Shop #: WSC 24977 002 1048576
ASAM Dataset: EV_ECM20TDI01103L906018BF 003008
ROD: EV_ECM20TDI01103L906018BF.rod
VCID: EFAE874A36FA27F3AA-80BA

No fault code found.
Readiness: 0 0 0 0 1

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 M HW: 3AA 614 109 M
Component: J104 C2 450M V4A1 0005
Revision: --H07--- Serial number: 00000004061796
Coding: 0002992
Shop #: WSC 00028 028 00001
VCID: B73E7F2AC62AAF33B2-80E2

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 5K0 907 044 DT HW: 5K0 907 044 DT
Component: Climatronic H17 1010
Revision: 00003001
Coding: 0000000003
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW46.rod
VCID: 804CD4F61B64288B43-80D4

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 3AA-937-087.clb
Part No SW: 3AA 937 087 A HW: 3AA 937 087 A
Component: BCM PQ47 H 413 0452
Revision: BB413001
Coding: 000000000000000000180080140081E443516488406C816064 80C7200041
Shop #: WSC 00028 028 00001
VCID: B83C7C160B34A04BBB-80EC

Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 09031 26 0612
Coding: 00B795

Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 120411 05 54 0403
Coding: 0330ED

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 HW: 7N0 919 475
Component: PARKHILFE 8K H04 0009
Revision: -------- Serial number: 28291107749682
Coding: 108001
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_EPHVA18VW47X0000 001003
ROD: EV_EPHVA18VW47X0000.rod
VCID: FCB4A006778C4C6B1F-80A8

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 R HW: 5N0 959 655 R
Component: J234__102 VW10 HI 1918
Revision: 22014000 Serial number: 003K0P6A0TT-
Coding: 0012338
Shop #: WSC 00028 028 00001
VCID: CCD430C6AFAC3CEBEF-8098

Subsystem 1 - Serial number: 6332MTS625650741

Subsystem 2 - Serial number: 6342MTS636660751

Subsystem 3 - Serial number: 6351HTS6N43CS9KR

Subsystem 4 - Serial number: 6361HTS6CMRIS9KR

Subsystem 5 - Serial number: 00000000000000000

Subsystem 6 - Serial number: 00000000000000000

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C5 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 014 0140
Revision: FF010040 Serial number: 20110408101598
Coding: 1182250000
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: F2A88E3E25C80A1B45-80A6

Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H06 0022
Coding: E20000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 970 A HW: 3AA 920 970 A
Component: KOMBI H20 0420
Serial number: 00000000000000
Coding: 460F00
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04089
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod
VCID: B12A4132E04E7103FC-80E4

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 G HW: 1K0 907 951
Component: J533 Gateway H41 1614
Revision: H41 Serial number: 080411F1001509
Coding: 461007
Shop #: WSC 00028 028 00001
VCID: B4244826175C442B97-80E0

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 HW: 3AA 959 433
Component: IMMO 043 0399
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: F6A0B22E81A0163B69-80A2

Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 D HW: 5N0 035 342 D
Component: SG EXT.PLAYER H13 0150
Revision: A1001003 Serial number: 7669743207
Coding: 020000
Shop #: WSC 00028 028 00001
VCID: A81CAC56DB9430CB2B-80FC

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C0 035 279 HW: 3C0 035 279
Component: RNS315 H05 0010
Serial number: VWZAZ2L3320713
Coding: 040004010400000000011000
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_RNS315VWEUV1UDS A01005
ROD: EV_RNS315VWEUV1UDS.rod
VCID: E08CF476FB24888B23-80B4

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 TUER-SG FT 002 05300530
Revision: 12110009 Serial number: 0002608904
Coding: 0202B7
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: B522752214265D23A0-80E0

Slave Driver:
Subsystem 1 - Part No: 3C0 959 704 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR
Coding: 000290

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 M
Component: EPS_ZFLS Kl. 195 3201
Revision: 00H20000
Shop #: WSC 00028 028 00001
VCID: B4244826D75C442B97-80E0

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 HW: 3AA 959 433
Component: KSG PQ47 ELV 043 0631
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 01910A0002860E76300494157C085FCE105C01
Shop #: WSC 18798 014 67328
VCID: F6A0B22E81A0163B69-80A2

Subsystem 1 - Part No: 1K8 951 605 B
Component: LIN BACKUP HORN H11 9005

Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611

Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611

No fault code found.

-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 1K0 907 951
Component: EZE_2 H41 1614
Revision: H41 Serial number: 080411F1001509
Coding: 00000008
Shop #: WSC 00028 028 00001
VCID: EFAE874A3EFA27F3AA-80BA

Subsystem 1 - Part No SW: 3AA 919 204 A HW: 3AA 919 204 A
Component: Analoguhr 004 0003

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0530
Revision: 14110009 Serial number: 0002615956
Coding: 0202B6
Shop #: WSC 00028 028 00021
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: B620722E0920563BA9-80E2

Slave Passenger:
Subsystem 1 - Part No SW: 3C0 959 703 HW: 3C0 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0408
Serial number: 00000002069667
Coding: 000290

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 E HW: 3AA 907 801 E
Component: J540 EPB4 VW-55183 0007
Revision: H18 Serial number: 00000000275996
Coding: 0022067
Shop #: WSC 00028 028 00001
VCID: B3264B3AD25243138E-80E6

No fault code found.

-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 1K0 907 951
Component: Batt.regelung H41 1614
Serial number: 080411F1001509
Coding: 030B185A
Shop #: WSC 00028 028 00001
VCID: F1AA813228CE3103BC-80A4

Subsystem 1 - Part No SW: 1K0 915 181 F HW: 1K0 915 181 A
Component: J367-BDM H07 0150
Serial number: 00000000009370130638

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 B HW: 3AA 907 273 B
Component: RDKBERU30 H08 0008
Serial number: 10000000029158
ASAM Dataset: EV_RDKBERU30 003010
ROD: EV_RDKBERU30_003.rod
VCID: B3264B3A1A5243138E-80E6

No fault code found.

End----------(Elapsed Time: 03:10, VBatt start/end: 14.7V/14.7V)-----------

[Chapster5]

Hi all,

2013 VW passat estate 2.0l blue motion

Thought I would jump on this thread. I don't have VCDS mind but I do have Carista which seems to pull some OK data from the car. Now I've got the bag code 01314 under a couple of modules when I scan the car. See below

ECU info obtained with Carista 8.3 beta-5 for Android:

VIN: WVWZZZ3CZDE134104

CAN network gateway
Part #: 7N0907530AH
Component: J533 Gateway
Software version: 1634
ASAM/ODX identifier: [none]
Coding: 462007 (hex)
Fault codes:
01300 Manufacturer-specific code
01314 Manufacturer-specific code
03272 Manufacturer-specific code

Engine
[ECU not present]

ABS
Part #: 3AA614109AQ
Component: J104 C2 450M V
Software version: [none]
ASAM/ODX identifier: [none]
Coding: 4016 (decimal)
Fault codes:
01314 Manufacturer-specific code
01325 Manufacturer-specific code

Parking brake
Part #: 3AA907801H
Component: J540 EPB4 VW-86
Software version: [none]
ASAM/ODX identifier: [none]
Coding: 22167 (decimal)
Fault codes:
01314 Manufacturer-specific code

Power steering
Part #: 1K0909144P
Component: EPS_ZFLS Kl. 195
Software version: [none]
ASAM/ODX identifier: [none]
Coding: [none]
Fault codes:
01314 Manufacturer-specific code
03803 Manufacturer-specific code

Steering angle
[ECU not present]

Steering wheel
Part #: 3C9953501BN
Component: LENKS.MODUL
Software version: 0140
ASAM/ODX identifier: EV_VW360SteerWheelUDS
Coding: 1182250000 (hex)
[No fault codes]

Airbags
Part #: 5N0959655AA
Component: J234__108 VW10 H
Software version: [none]
ASAM/ODX identifier: [none]
Coding: 12344 (decimal)
[No fault codes]

Instrument cluster
Part #: 3AA920970J
Component: KOMBI
Software version: 0705
ASAM/ODX identifier: EV_Kombi_UDS_VDD_RM09
Coding: 761D01 (hex)
Fault codes:
12648448 Manufacturer-specific code

Navigation
[ECU not present]

Radio
[ECU not present]

Media player
[ECU not present]

Immobilizer
Part #: 3AA959433B
Component: IMMO
Software version: [none]
ASAM/ODX identifier: [none]
Coding: [none]
[No fault codes]

Tire pressure monitor
[ECU not present]

Heater & air conditioning
Part #: 3AA907044AF
Component: Climatronic
Software version: 0303
ASAM/ODX identifier: EV_Climatronic
Coding: 0014004803 (hex)
Fault codes:
13701376 Manufacturer-specific code

Parking/steering assist
Part #: 3AE919475C
Component: PARKHILFE 8K
Software version: 0018
ASAM/ODX identifier: EV_EPHVA18VW47X0000
Coding: 108002 (hex)
[No fault codes]

Central electronics
Part #: 3AA937087F
Component: BCM PQ47 M
Software version: 0465
ASAM/ODX identifier: [none]
Coding: 000800000000000000980080100000E447710088426D816064 80C7200041 (hex)
Fault codes:
01314 Manufacturer-specific code
01518 Manufacturer-specific code
01519 Manufacturer-specific code
02394 Manufacturer-specific code
02395 Manufacturer-specific code
02745 Manufacturer-specific code
02746 Manufacturer-specific code
03678 Manufacturer-specific code
00526 Manufacturer-specific code
00978 Manufacturer-specific code
00979 Manufacturer-specific code

Central electronics 2
Part #: 7N0907532
Component: EZE_2
Software version: 1634
ASAM/ODX identifier: [none]
Coding: 00000008 (hex)
[No fault codes]

Body/convenience system
Part #: 3AA959433B
Component: KSG PQ47 ELV
Software version: [none]
ASAM/ODX identifier: [none]
Coding: 18910A0052830E7634049C1D7C085FCE105C04 (hex)
[No fault codes]

Driver's door
Part #: 3AA959701A
Component: TUER-SG FT
Software version: 0534
ASAM/ODX identifier: EV_TSGFPQ35BRFVW46X
Coding: 0202B7 (hex)
Fault codes:
68108 Manufacturer-specific code

Front passenger's door
Part #: 3AA959702A
Component: TUER-SG BT
Software version: 0534
ASAM/ODX identifier: EV_TSGBPQ35BRFVW46X
Coding: 0202B6 (hex)
Fault codes:
68108 Manufacturer-specific code

Rear left door
[ECU not present]

Rear right door
[ECU not present]

Battery regulator
Part #: 7N0907534
Component: Batt.regelung
Software version: 1634
ASAM/ODX identifier: [none]
Coding: 030F1859 (hex)
[No fault codes]

I've put a brand new battery in today and cleared the fault codes but to no avail. The car refuses to start until I put the key in and out about 4/5 time it eventually kicks into life but the ESP, ABS, TPMS and Engine light all illuminate as well as the electronic parking brake.

I've managed to drive the car a little bit and found sometimes it will cut out then start again whilst driving it's only started happening since Friday it's been great for the past 4 years. Any ideas? Please

Thank you!

[Crasher]

Did this just happen or happen after fitting the battery? What are the exact details of the battery?

[Chapster5]

Hi mate thanks for the response

So little bit of back story... The battery that was on the car was fitted 4 years ago and lasted well until the past 2 months I've got a company van now so the car doesn't get used daily like it normally does the battery had dropped to a voltage like 10.9v and was no longer holding charge so every day after work I'd start the car and take it for a little drive it was laboursome to start and one time didn't start what so ever and stored a code of a low voltage on the basic obd.

Took the car tk have the health checked on thr battery out of the 760ah only 350ah remained so it was a replace the battery kind of job. Anyway with me having the van I thought I'll deal with the battery in the new year it'll be fine... Until I took my car last Friday... It started fine, drove fine, fuelled up, went to my nans (15 miles away) got back in the car and started fine set off and within 3 yards it cut out with all those lights on the dash above. So I stopped tried starting it again and nothing so tried 2 more times and it burst back into life with those same lights. I drove it home as I was driving the fault lights slowly switched off one by one.

Got home then nipped to a friend's then when I was leaving after abojt an hour tried starting the car again... Boom all the lights are back and no start won't even attempt to crank. Again key in and out a couple times got the car going but as I was driving away the revs kept dropping to 0 then back up again (did this twice)...

Next day tried to start it and it wouldn't start again all the lights and scanned for faults to find the ones above so today I thought I'll replace the battery maybe the voltage is a little low and the car is just throwing its dummy out but it never solved the issue unfortunately.

I can get it going and clear the faults and they remain cleared until I turn the car off and start it again they appear again.

Does this help at all?

Cheers!

Nick

[Chapster5]

Did this just happen or happen after fitting the battery? What are the exact details of the battery?

Do you think if I removed the ecu and brought it into a warm environment for a few hours it may help? I lifted the scuttle panel slightly and put my hand on top the ecu and there was a puddle of water (well it was on top of a plastic casing on the ecu) the connectors felt dry though

[Crasher]

I would be surprised if it did.

[Chapster5]

I would be surprised if it did.

Any ideas where to look or start looking on it do you need a reg for diagrams? I'm hoping it's something like a relay rather than ecu

[Crasher]

What is the VIN and the details of the battery fitted? ECU failure is extremely rare.

[Chapster5]

What is the VIN and the details of the battery fitted? ECU failure is extremely rare.

This is the VIN

WVWZZZ3CZDE134104

The battery is a YUASA 9096 70Ah 760CCA AGM battery. Same as what has been on the car the past 4 years I replaced it like for like I even programmed the new battery in on both canbus and voltage regulator.

[Crasher]

I wouldn't fit a Yuasa 9000 series to my worst enemies car but lets assume it is fine and that spec is corcet, a match for the OE 000 915 105 CC.

You have coms with some modules, importantly the CAN so I would start by fitting a new line 30 relay in the engine bay fuse box, part number 4H0 951 253. This is at position 4 and the old version has 100 printed on top whereas the revised version is 644.

[Chapster5]

I wouldn't fit a Yuasa 9000 series to my worst enemies car but lets assume it is fine and that spec is corcet, a match for the OE 000 915 105 CC.

You have coms with some modules, importantly the CAN so I would start by fitting a new line 30 relay in the engine bay fuse box, part number 4H0 951 253. This is at position 4 and the old version has 100 printed on top whereas the revised version is 644.

Perfect I'll get one ordered! I'll get it plugged in and see what happens bud maybe the old relay has given up the ghost?

I spoke to another mechanic who suggested maybe a bad earth somewhere as well

[Crasher]

The same relay went semi faulty on my business partners 2018 Tiguan and the car went crazy, spinning the fans, flattening the battery, cutting the car out… all sorts, it looked like a major sketch and the fault code read was silly, red ink on every controller. I went onto erWin, looked up the symptoms and there was a spot on TPI about it.

[Chapster5]

The same relay went semi faulty on my business partners 2018 Tiguan and the car went crazy, spinning the fans, flattening the battery, cutting the car out… all sorts, it looked like a major sketch and the fault code read was silly, red ink on every controller. I went onto erWin, looked up the symptoms and there was a spot on TPI about it.

Sounds like what mines doing bud!

Soon as the car starts (or at least ignition on) the fans spin up (it is part way through a dpf regen which won't help the fans spinning mind) but that's with the car cold and the old battery was being drained so sounds like it could be a likely cause!

So it's the only relay in the under bonnet fuse box that I have tk replace that has 100 written on the top

[Crasher]

If it is 100 it is the old version, the replacement is 644, there are two in there, the one to be changed is at position 4

https://live.staticflickr.com/65535/49945164053_e078a7b89a_k.jpg (https://flic.kr/p/2j6u2da)

[Chapster5]

If it is 100 it is the old version, the replacement is 644, there are two in there, the one to be changed is at position 4

https://live.staticflickr.com/65535/49945164053_e078a7b89a_k.jpg (https://flic.kr/p/2j6u2da)

Ah mines only got 1 relay in the fuse board the other relay slot has a metal audi/vw bar bridging across 2 of the big pins?

Ive had a friend scan it properly with a snap on computer and it flags up as cannot connect to the ecu there's a short to open on terminal 30. We took the relay out and took the cover off and with the ignition on we touched the relay off and on a few times and watched it open and close with every touch then reinstalled the relay the car fired right up so we cleared the codes and drove it for a bit and no issues whilst he monitored the cars live data and terminal 30 data and all seemed well

Came to the car today straight away non start won't crank same issue so I put the ignition on and took the relay out did what we did the previous night touched it off and on a few times watched it open and close then tried starting the car again and fired into life again. Idled for about 2 minutes then the car cut out and stopped so think it's a sticky relay or the relay is caput completley and not maintaining connection. I've ordered a 644 to arrive on Wednesday all being well and I can cross my fingers and hope it fires right up as we can read the ecu no problems and code it and stuff so can't be an ecu fault.

[Crasher]

ECU failure is extremely rare, we see approx 1 per year. We have a 2004 Passat 3B in at the moment with a suspected ECU problem but it is obsolete so we are trying a used one; fortunately we have the VAG equipment to make this quick and easy.

[Chapster5]

ECU failure is extremely rare, we see approx 1 per year. We have a 2004 Passat 3B in at the moment with a suspected ECU problem but it is obsolete so we are trying a used one; fortunately we have the VAG equipment to make this quick and easy.

I'll keep you posted buddy!

[Chapster5]

ECU failure is extremely rare, we see approx 1 per year. We have a 2004 Passat 3B in at the moment with a suspected ECU problem but it is obsolete so we are trying a used one; fortunately we have the VAG equipment to make this quick and easy.
OK so new relay came today and replaced the old relay. Still the same faults and non start. I've managed to get the engine running once or twice and clear all the codes but after about 2-5 mins of idling the engine cuts out with all the same codes again. Mainly 01314. Not sure where to looks from here. I've checked all fuses under the bonnet but they all look new and in tact?

[spud72UK]

I have the same by the sounds of it on our 2007 1.9 TDI Golf plus, immobilisers and battery light only when I try to start it (cranks but doesnt fire) fans come on at full speed. Occasionally will start and drive ok. Swapped relay 100 with a known good one and the same results. Fingers crossed that it is a broken wire. Some times after leaving ignition on for about 30 seconds the relays click and it can be started.

[Chapster5]

ECU failure is extremely rare, we see approx 1 per year. We have a 2004 Passat 3B in at the moment with a suspected ECU problem but it is obsolete so we are trying a used one; fortunately we have the VAG equipment to make this quick and easy.
Do you by any chance have an ecu pinout for my vin bud?

[Crasher]

VAG don't provide them, they provide a wiring diagram with socket numbers.

[Chapster5]

VAG don't provide them, they provide a wiring diagram with socket numbers.

Ahhh I thought you might have them I have an ecu guy coming tomrorow to remove the ecu and bench test it and see if its faulty. If not I'm down to finding a faulty wire apparently I need to start at the wire that connects the T30 relay to the ecu but no clue which pins to which

[Crasher]

ECU bench testing is a waste of time and money, I don't trust any of them even Bosch themselves in Germany with their own test and repair service, they have still let me down. ECU's rarely fail although I had two last week.

[Chapster5]

ECU bench testing is a waste of time and money, I don't trust any of them even Bosch themselves in Germany with their own test and repair service, they have still let me down. ECU's rarely fail although I had two last week.

So the ecu guy is pretty confident after looking at the car and plugging it in that it isn't the ecu at fault here as the car wouldn't run for as long as it does and once it's started and faults cleared if you turn it off and turn it back on again it starts just fine. So thinking a damaged wire or maybe dart strap somewhere on the car.

This is a pain

[Crasher]

I have tried two used ECU's for the A4 I am fighting and both had different faults to the original...:aargh4: :banghead:

[Chapster5]

I have tried two used ECU's for the A4 I am fighting and both had different faults to the original...:aargh4: :banghead:

If it makes you feel any better I'm struggling to find an auto electrician in my area with availability

[Crasher]

Car electrics are getting out of control, we are fighting problems with 14 year old designs where the parts are going obsolete and used part’s won’t work… what is going to happen with the cars being made now when they are 15 years old and the security systems lock anyone out who isn’t authorised by VW? There is a new feature called SFD for anything new model post 2020 that even stops you replacing the rear pads unless you are SFD access cleared with two factor authentication password one time access codes and SFD 2 is coming… I want to retire.

[Chapster5]

Car electrics are getting out of control, we are fighting problems with 14 year old designs where the parts are going obsolete and used part’s won’t work… what is going to happen with the cars being made now when they are 15 years old and the security systems lock anyone out who isn’t authorised by VW? There is a new feature called SFD for anything new model post 2020 that even stops you replacing the rear pads unless you are SFD access cleared with two factor authentication password one time access codes and SFD 2 is coming… I want to retire.

Quick update...

Still no further forward. Replaced 2 relays under the dashboard that an auto electrician said is common on them but still the same fault urgh.

[spud72UK]

I have the same by the sounds of it on our 2007 1.9 TDI Golf plus, immobilisers and battery light only when I try to start it (cranks but doesnt fire) fans come on at full speed. Occasionally will start and drive ok. Swapped relay 100 with a known good one and the same results. Fingers crossed that it is a broken wire. Some times after leaving ignition on for about 30 seconds the relays click and it can be started.
-
Had to take mine to our local friendly garage as I couldn't sus out the problem as it was very intermittent - mine turned out to be an bad ECU unfortunately (luckily they managed to get a 2nd hand one) - All sorted thanks to A & T Automotive in Woking Surrey.

[Crasher]

I sent the first replacement ECU to ACTronics for testing as it only had the one repeat code for the manifold but it came back as OK so now the finger of suspicion points to the FEBI replacement manifold which would be highly unusual so what to do? Do I try Pierburg or genuine only to get the same result as my gut instinct still says ECU?

[VolksPhil]

Hi Crasher,

Another thread revival! I found this thread and it seems like I have very similar issues to a lot of other posters so I'm going to start following some of the fault finding and see how I get on. I'll probably start by checking the condition of my ECU and seeing if there is any water ingress or other visible issues. My car is a 2013 Passat Estate 365 variant, CFFB with stop start and NFU gearbox. I last used the car on Sunday - no issues, came to use the car on Monday - lots of lights and not even a click on the starter motor. I ensured the battery was fully charged overnight into Tuesday and at one point did manage to get my car to start but still had a flashing glowplug symbol, so wanted to switch the engine off before I connected any diagnostics. But once I connected the diags and tried restarting, I had the same 'large number' of flashing lights. Lots of my symptoms resonate with other posters so I'm hopeful that this thread (and possibly your assistance) might get me moving again. Is there any particular order of things to check or ECU, 100 relay, all fuses then... start at your first post (post 9?) and go from there?

[VolksPhil]

Any clues as to how to remove this style of ECU plug?https://uploads.tapatalk-cdn.com/20250219/a1ebeab746026932090bd70456d696f5.jpg

Sent from my M2101K6G using Tapatalk

[VolksPhil]

Here's a vid of my dashboard lights
- YouTube (https://youtube.com/shorts/bJ_FvY17meA)
Strangely, whilst trying to work out what's wrong, I've actually had it turn over on 2 occasions but not start, start on one occasion - then cut out after 30-40 seconds, now I just get the lights as shown. I've checked the '100' relay and that operates (as far as I know) correctly and I get different dash lights if it is not in circuit.

[VolksPhil]

I've managed to get my ECU plug off / out (cut slots in the anti tamper screws than used an impact driver to loosen them before unscrewing and slightly bending the plate to be able to remove it). have 'pluged and removed' a few times to try and help clean any terminals etc - still no joy starting but I don't have the flashing lights on ign on, I now get:
39593
But this was also how I saw the lights this morning before I tried anything, so I'm 99% sure it is not connected with me removing the ECU.

I've also done another scan and I get (amongst others) Address 01: Engine Cannot be reached and Address 19: CAN Gateway (J533) 1 Fault Found: 01314 - Engine Control Module 004 - No Signal/Communication

So do I need to dig into my central console and start checking the CAN module / plug / wires? I believe it is behind the Air con controls / and or radio area.

[Crasher]

I have your VIN from your PM, can you post a full scan from VCDS as a .txt file?

[VolksPhil]

Many thanks Crusher - much appreciated!

I'm not quote sure how to post it as a .txt file , so here's a copy/paste from that file. This was from before I disconnected / removed the ECU





Chassis Type: 3C-VW46 (7N0)Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 69 72

01-Engine -- Status: Malfunction 1110
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
53-Parking Brake -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: Malfunction 0010
72-Door, Rear Right -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine
Cannot be reached

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 AP HW: 3AA 614 109 AP
Component: J104 C2 450M V40A 0030
Revision: --H07--- Serial number: 00000007626894
Coding: 0002992
Shop #: WSC 05311 000 00000
VCID: 7BF542EB3AE5695797-802E

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 3AA 907 044 BT HW: 3AA 907 044 BT
Component: Climatronic H05 0505
Revision: 00001K02
Coding: 061400C803
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW36.rod (VIN: N/A)
VCID: 03053A0B8A151197DF-8056

1 Fault Found:
13701376 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 3AA-937-087.clb
Part No SW: 3AA 937 087 P HW: 3AA 937 087 P
Component: BCM PQ47 H 422 0474
Revision: BB422001
Coding: 0008000000000000009800805400816403510088426D876064 80C7200041
Shop #: WSC 05311 000 00000
VCID: 479DEE1BF6ADFDB743-8012

Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 30101 26 0612
Coding: 00B795

Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 311013 05 54 0403
Coding: 2230ED

3 Faults Found:
00833 - Signal for Activation of Heated Windshield
009 - Open or Short to Ground - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication
03678 - Coordinator for Start-Stop Operation
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 C HW: 7N0 919 475
Component: PARKHILFE 8K H06 0018
Revision: -------- Serial number: 28231329103692
Coding: 118002
Shop #: WSC 99999 1023 2097151
ASAM Dataset: EV_EPHVA18VW47X0000 001006
ROD: EV_EPHVA18VW47X0000.rod (VIN: N/A)
VCID: 3F8DF6FBA67DB577FB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 AA HW: 5N0 959 655 AA
Component: J234__108 VW10 HI 2518
Revision: 27019000 Serial number: 003L7PP2DZHJ
Coding: 0012344
Shop #: WSC 05311 000 00000
VCID: 7CF741F73FEB6E6F9E-8028

Subsystem 1 - Serial number: 6332MTS617962873

Subsystem 2 - Serial number: 6342MTS609662873

Subsystem 3 - Serial number: 6351HTS6JLLRECKR

Subsystem 4 - Serial number: 6361HTS69AJIFCKJ

Subsystem 5 - Serial number: 00000000000000000

Subsystem 6 - Serial number: 00000000000000000

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C9 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 016 0140
Revision: FF010042 Serial number: 20131008201503
Coding: 118A250000
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod (VIN: N/A)
VCID: 76E353DFC9C7343FE8-8022

Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H07 0022
Coding: E20000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 980 N HW: 3AA 920 980 N
Component: KOMBI H04 0611
Serial number: 00000000000000
Coding: 461F00
Shop #: WSC 05314 115 12345
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod (VIN: N/A)
VCID: 3F8DF6FBA67DB577FB-806A

1 Fault Found:
12648448 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AN HW: 7N0 907 530 AN
Component: J533 Gateway H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 462007
Shop #: WSC 05314 000 00000
VCID: 7CF741F7FFEB6E6F9E-8028

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: IMMO 043 0407
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: 387F9DE74B53824F3A-806C

Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 G HW: 5N0 035 342 G
Component: SG EXT.PLAYER H19 0770
Revision: A1001003 Serial number: 7665337526
Coding: 020100
Shop #: WSC 05314 000 00000
VCID: 2B55B2AB4A0539D747-807E

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C8 035 279 G HW: 3C8 035 279 G
Component: RNS315-EU H76 0410
Serial number: VWZAZ2N0601260
Coding: 040004010400110000011002
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_RNS315EUV2UDS 001705
ROD: EV_RNS315EUV2UDS.rod
VCID: 2F6DA6BB761D45F76B-807A

Data carrier:
Subsystem 1 - Part No: 3AA 919 866
Component: EUR_W_V12 0078

1 Fault Found:
1048598 - Front Right Treble Speaker
B1064 13 [009] - Open Circuit
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 0534
Revision: 12110009 Serial number: 0007695044
Coding: 0212B7
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: 356194D394417F2721-8060

Slave Driver:
Subsystem 1 - Part No SW: 3AA 959 704 A HW: 3AA 959 794 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 004 0503
Serial number: 00000003720677
Coding: 010290

1 Fault Found:
68108 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 R
Component: EPS_ZFLS Kl. 195 3501
Revision: 00H22000
Shop #: WSC 02069 000 90108
VCID: 397998E370599B47C5-806C

2 Faults Found:
03803 - Steering Angle Sensor for Steering Aid
000 - - - MIL ON
01314 - Engine Control Module
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: KSG PQ47 ELV 043 0645
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 0191020052830E76340C94157C085FCE105C04
Shop #: WSC 05311 000 00000
VCID: 387F9DE74B53824F3A-806C

Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H05 1501

Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611

Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611

No fault code found.

-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 7N0 907 530 AN
Component: EZE_2 H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 050B0508
Shop #: WSC 05314 000 00000
VCID: 6FED66BBBE9D05F72B-803A

Subsystem 1 - Part No SW: 7N0 959 591 B HW: 7N0 959 591 B
Component: J245EE04SKB03 H03 0090
Serial number: 0123456789ABCDEFGHIJ

Subsystem 2 - Part No SW: 7N0 959 591 B HW: 7N0 959 591 B
Component: J394EE04SKB03 H03 0090
Serial number: 0123456789ABCDEFGHIJ

Subsystem 3 - Part No SW: 3AA 919 204 A HW: 3AA 919 204 A
Component: Analoguhr 004 0004

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0534
Revision: 14110009 Serial number: 0007704561
Coding: 0212B6
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: 366393DF8947743F28-8062

Slave Passenger:
Subsystem 1 - Part No SW: 3AA 959 703 A HW: 3AA 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0503
Serial number: 00000003721958
Coding: 010290

1 Fault Found:
68108 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear

-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 H HW: 3AA 907 801 H
Component: J540 EPB4 VW-86594 0010
Revision: H19 Serial number: 00000001606578
Coding: 0022167
Shop #: WSC 05311 000 00000
VCID: 366393DF4147743F28-8062

4 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication
03182 - Clutch Position Sensor (G476)
010 - Open or Short to Plus - Intermittent
01314 - Engine Control Module
008 - Implausible Signal
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent

-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 7N0 907 530 AN
Component: Batt.regelung H56 1642
Serial number: 131013F2000903
Coding: 330F1859
Shop #: WSC 05314 000 00000
VCID: 71E960C3A8A913073D-8024

Subsystem 1 - Part No SW: 1K0 915 181 H HW: 1K0 915 181 A
Component: J367-BDM H07 0180
Serial number: 40304F47221491365162

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 D HW: 3AA 907 273 D
Component: RDKBERU30 H09 0010
Serial number: 30000000008106
ASAM Dataset: EV_RDKBERU30 003012
ROD: EV_RDKBERU30_003.rod
VCID: 356194D394417F2721-8060

No fault code found.

-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:. 7N0-907-383.clb
Part No SW: 7N0 907 383 HW: 7N0 907 383
Component: Anhaenger H09 0120
Revision: 3I001003 Serial number: 00008160140260
Coding: 4106040001000000
Shop #: WSC 05314 000 00000
VCID: 73E56ACBD2B52117CF-8026

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication
00532 - Supply Voltage B+
011 - Open Circuit - Intermittent - MIL ON
End---------------------(Elapsed Time: 04:11, udsna)-----------------------

[VolksPhil]

I was also going to add a current video of my startup lights but YouTube isn't playing ball at the moment.....
I'll keep trying.

It's still not playing ball so here's a picture of the 'steady state', once the start-up routine has completed - about 13 seconds after key in.
39594

Finally - YouTube is playing ball - https://youtu.be/wCHAhwwJyWY

[VolksPhil]

A new day - same car - different results! Arrgh!
I left it yesterday with the dash lights and readout as per my post above.
Tried it again a short while ago - I thought I'd just see what I'm getting today. VCDS was already plugged in, so I attempted a start - it started! Whaaat?? Let it idle for a few mins, revved it up to 2500rpm (it wouldn't rev above 2500rpm). Whilst it was running, ran VCDS full test. Found faults, cleared them, ran a second test, found fewer faults, cleared them (but obviously failed to record this in the log). stopped engine - tried a restart - it restarted (still no rev above 2500rpm).

Stopped the engine and did another fault code clear and another full sweep. Disconnected VCDS, tried another restart - restarted fine, no dash lights. I haven't driven it anywhere as I currently have no confidence in it - so as far as I'm concerned, it is still 'broken' as I haven't actually changed anything and other than plugging / unplugging a few items, nothing has changed (except outside temp - but I didn't have any issues when it was around -2 C a few weeks ago).

VCDS as follows:
Also - as seen in the 1st bit of readout - it shows 1205 rpm but speed at 60km/h!!! I was sat stationary on my drive.


Friday,21,February,2025,16:08:43:00009

Mileage: 207140km-128710mi Repair Order: 292592211608


--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 3C-VW46 (01 - WD63OPT)
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 69 72

VIN: Mileage: 207140km-128710miles
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFFB) Labels:. 03L-906-018-CFF.clb
Part No SW: 03L 906 018 PR HW: 03L 907 309 AE
Component: R4 2,0L EDC X28 4006
Revision: 41X28--- Serial number: 00000000000000 CVN: DE61F492
Coding: 00190012043501080000
Shop #: WSC 92521 052 00000
ASAM Dataset: EV_ECM20TDI01103L906018PR 003004
ROD: EV_ECM20TDI01103L906018PR.rod
VCID: 09192823A8394BC795-805C
VINID: 9E69EAAAA0D3A95540204046043A8F1A88


5 Faults Found:
4481 - Cruise Control Switch (E45)
P0568 00 [032] - Implausible Signal
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 206707 km
Date: 2125.14.19
Time: 11:01:38


Engine RPM: 1205.50 /min
Normed load value: 0.0 %
Vehicle speed: 60 km/h
Coolant temperature: 77 °C
Intake air temperature: 10 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 14.940 V
Unlearning counter according OBD: 29
Cruise Control System (CCS): switch position-Bits 0-7: 128
Cruise Control System (CCS): status-Bits 0-7: 8
Cruise control switch-off: irreversible-Bits 0-7: 255
Cruise control switch-off: reversible-Bits 0-7: 7
Cruise Control System: specified speed: 0.00 km/h
Engine control module reset status-Bits 0-7: 0
Engine control module reset status-Bits 0-7: 0
Cruise control switch-off: irreversible w. brake intervention-Bits 0-7: 0


4483 - Function Restriction due to Faults in Other Modules
U1113 00 [032] - -
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Mileage: 206707 km
Date: 2125.14.19
Time: 11:01:38


Engine RPM: 1204.00 /min
Normed load value: 0.0 %
Vehicle speed: 59 km/h
Coolant temperature: 77 °C
Intake air temperature: 9 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 14.960 V
Unlearning counter according OBD: 29
Cruise Control System (CCS): switch position-Bits 0-7: 192
Cruise Control System (CCS): status-Bits 0-7: 200
Cruise control switch-off: irreversible-Bits 0-7: 0
Cruise control switch-off: reversible-Bits 0-7: 7
Cruise Control System: specified speed: 0.00 km/h
Engine control module reset status-Bits 0-7: 0
Engine control module reset status-Bits 0-7: 0
Cruise control switch-off: irreversible w. brake intervention-Bits 0-7: 1


5174 - Fuel Pressure Regulation
P1065 00 [096] - Regulation Discrepancy
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 207037 km
Date: 2127.14.06
Time: 11:38:38


Engine RPM: 1252.50 /min
Normed load value: 62.0 %
Vehicle speed: 49 km/h
Coolant temperature: 50 °C
Intake air temperature: 5 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 14.700 V
Unlearning counter according OBD: 37
Engine status: COENG_RUNNING
Engine status-Test_Program_Co Eng st COMPU VERB UBYTE: 3


4629 - ECM Power Relay Load Circuit
P068A 00 [032] - Opens Too Early
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 0 km
Date: 2000.00.00
Time: 00:00:00


Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: -40 °C
Intake air temperature: -40 °C
Ambient air pressure: 0 mbar
Voltage terminal 30: 0.000 V
Unlearning counter according OBD: 40
Accelerator pedal travel: 0.00 %
Starter control: Interlock- or P/N-signal-Bits 0-7: 0
Engine status: COENG_STANDBY
Engine status-Test_Program_Co Eng st COMPU VERB UBYTE: 0


4611 - Control Module Malfunction - DBW Throttle Monitoring
P1388 00 [167] - -
MIL ON - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 2
Date: 2000.00.00
Time: 00:00:00


Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 29 °C
Intake air temperature: 13 °C
Ambient air pressure: 990 mbar
Voltage terminal 30: 12.460 V
Unlearning counter according OBD: 40
Speed regulation requested torque: 1207.7 Nm
Accelerator pedal travel: 0.00 %
Accelerator pedal: sensor voltage 1: 752.4 mV
Accelerator pedal: sensor voltage 2: 381.0 mV
Control Module temperature: 6.4 °C
Outside temperature: 13.0 °C


Readiness: 0 0 0 0 0


-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 AP HW: 3AA 614 109 AP
Component: J104 C2 450M V40A 0030
Revision: --H07--- Serial number: 00000007626894
Coding: 0002992
Shop #: WSC 05311 000 00000
VCID: 7BF542EB3AE5695797-802E


2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 3
Fault Frequency: 26
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 23:03:53


Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 11.25 V
Bin. Bits: 00011111
Count: 220
Hex Value: 0x0000


01314 - Engine Control Module
013 - Check DTC Memory
Freeze Frame:
Fault Status: 00100100
Fault Priority: 3
Fault Frequency: 26
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 23:03:53


Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 11.25 V
Bin. Bits: 00011111
Count: 220
Hex Value: 0x0000




-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 3AA 907 044 BT HW: 3AA 907 044 BT
Component: Climatronic H05 0505
Revision: 00001K02
Coding: 061400C803
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW46.rod
VCID: 03053A0B8A151197DF-8056


1 Fault Found:
13701376 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 10
Reset counter: 50
Mileage: 207141 km
Date: 2127.14.31
Time: 23:03:51




-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 3AA-937-087.clb
Part No SW: 3AA 937 087 P HW: 3AA 937 087 P
Component: BCM PQ47 H 422 0474
Revision: BB422001
Coding: 0008000000000000009800805400816403510088426D876064 80C7200041
Shop #: WSC 05311 000 00000
VCID: 479DEE1BF6ADFDB743-8012


Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 30101 26 0612
Coding: 00B795


Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 311013 05 54 0403
Coding: 2230ED


2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 6
Fault Frequency: 8
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 23:03:53


Freeze Frame:
Term 15 On
Voltage: 11.45 V
ON
ON
ON
OFF
OFF


03678 - Coordinator for Start-Stop Operation
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 6
Fault Frequency: 8
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 23:03:53


Freeze Frame:
Term 15 On
Voltage: 11.45 V
ON
ON
ON
OFF
OFF




-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 C HW: 7N0 919 475
Component: PARKHILFE 8K H06 0018
Revision: -------- Serial number: 28231329103692
Coding: 118002
Shop #: WSC 99999 1023 2097151
ASAM Dataset: EV_EPHVA18VW47X0000 001006
ROD: EV_EPHVA18VW47X0000.rod
VCID: 3F8DF6FBA67DB577FB-806A


No fault code found.


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 AA HW: 5N0 959 655 AA
Component: J234__108 VW10 HI 2518
Revision: 27019000 Serial number: 003L7PP2DZHJ
Coding: 0012344
Shop #: WSC 05311 000 00000
VCID: 7CF741F73FEB6E6F9E-8028


Subsystem 1 - Serial number: 6332MTS617962873


Subsystem 2 - Serial number: 6342MTS609662873


Subsystem 3 - Serial number: 6351HTS6JLLRECKR


Subsystem 4 - Serial number: 6361HTS69AJIFCKJ


Subsystem 5 - Serial number: 00000000000000000


Subsystem 6 - Serial number: 00000000000000000


No fault code found.


-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C9 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 016 0140
Revision: FF010042 Serial number: 20131008201503
Coding: 118A250000
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: 76E353DFC9C7343FE8-8022


Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H07 0022
Coding: E20000


No fault code found.


-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 980 N HW: 3AA 920 980 N
Component: KOMBI H04 0611
Serial number: 00000000000000
Coding: 461F00
Shop #: WSC 05314 115 12345
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod
VCID: 3F8DF6FBA67DB577FB-806A


1 Fault Found:
12648448 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 16
Reset counter: 50
Mileage: 207141 km
Date: 2025.02.21
Time: 23:03:51




-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AN HW: 7N0 907 530 AN
Component: J533 Gateway H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 462007
Shop #: WSC 05314 000 00000
VCID: 7CF741F7FFEB6E6F9E-8028


1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00110100
Fault Priority: 2
Fault Frequency: 18
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 23:03:53




-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: IMMO 043 0407
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: 387F9DE74B53824F3A-806C


Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380


No fault code found.


-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 G HW: 5N0 035 342 G
Component: SG EXT.PLAYER H19 0770
Revision: A1001003 Serial number: 7665337526
Coding: 020100
Shop #: WSC 05314 000 00000
VCID: 2B55B2AB4A0539D747-807E


No fault code found.


-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C8 035 279 G HW: 3C8 035 279 G
Component: RNS315-EU H76 0410
Serial number: VWZAZ2N0601260
Coding: 040004010400110000011002
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_RNS315EUV2UDS 001705
ROD: EV_RNS315EUV2UDS.rod
VCID: 2F6DA6BB761D45F76B-807A


Data carrier:
Subsystem 1 - Part No: 3AA 919 866
Component: EUR_W_V12 0078


1 Fault Found:
1048598 - Front Right Treble Speaker
B1064 13 [009] - Open Circuit
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 10
Mileage: 207141 km
Date: 2025.02.21
Time: 23:03:54




-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 0534
Revision: 12110009 Serial number: 0007695044
Coding: 0212B7
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: 356194D394417F2721-8060


Slave Driver:
Subsystem 1 - Part No SW: 3AA 959 704 A HW: 3AA 959 794 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 004 0503
Serial number: 00000003720677
Coding: 010290


1 Fault Found:
68108 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 50
Mileage: 207141 km
Date: 2025.02.21
Time: 00:00:45




-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 R
Component: EPS_ZFLS Kl. 195 3501
Revision: 00H22000
Shop #: WSC 02069 000 90108
VCID: 397998E370599B47C5-806C


1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 3
Fault Frequency: 6
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 00:00:49


Freeze Frame:
Voltage: 12.38 V
DU
Temperature: 14.0°C
RPM: 1498 /min
Speed: 0.0 km/h
Speed: 0.0 km/h
Count: 0




-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: KSG PQ47 ELV 043 0645
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 0191020052830E76340C94157C085FCE105C04
Shop #: WSC 05311 000 00000
VCID: 387F9DE74B53824F3A-806C


Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H05 1501


Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611


Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611


No fault code found.


-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 7N0 907 530 AN
Component: EZE_2 H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 050B0508
Shop #: WSC 05314 000 00000
VCID: 6FED66BBBE9D05F72B-803A


Subsystem 1 - Part No SW: 7N0 959 591 B HW: 7N0 959 591 B
Component: J245EE04SKB03 H03 0090
Serial number: 0123456789ABCDEFGHIJ


Subsystem 2 - Part No SW: 7N0 959 591 B HW: 7N0 959 591 B
Component: J394EE04SKB03 H03 0090
Serial number: 0123456789ABCDEFGHIJ


Subsystem 3 - Part No SW: 3AA 919 204 A HW: 3AA 919 204 A
Component: Analoguhr 004 0004


No fault code found.


-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0534
Revision: 14110009 Serial number: 0007704561
Coding: 0212B6
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: 366393DF8947743F28-8062


Slave Passenger:
Subsystem 1 - Part No SW: 3AA 959 703 A HW: 3AA 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0503
Serial number: 00000003721958
Coding: 010290


1 Fault Found:
68108 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 50
Mileage: 207141 km
Date: 2025.02.21
Time: 00:00:45




-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 H HW: 3AA 907 801 H
Component: J540 EPB4 VW-86594 0010
Revision: H19 Serial number: 00000001606578
Coding: 0022167
Shop #: WSC 05311 000 00000
VCID: 366393DF4147743F28-8062


4 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 41
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 15:15:26


Freeze Frame:
Voltage: 11.20 V
Count: 71
Speed: 0.0 km/h
Hex Value: 0x1263
Hex Value: 0x0001
Hex Value: 0x1010


03182 - Clutch Position Sensor (G476)
010 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 50
Time Indication: 0


Freeze Frame:
Voltage: 11.90 V
Count: 55
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010


01314 - Engine Control Module
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01111101
Fault Priority: 2
Fault Frequency: 5
Reset counter: 10
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 00:00:28


Freeze Frame:
Voltage: 11.70 V
Count: 65
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010


01314 - Engine Control Module
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 00:00:31


Freeze Frame:
Voltage: 11.80 V
Count: 61
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010




-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 7N0 907 530 AN
Component: Batt.regelung H56 1642
Serial number: 131013F2000903
Coding: 330F1859
Shop #: WSC 05314 000 00000
VCID: 71E960C3A8A913073D-8024


Subsystem 1 - Part No SW: 1K0 915 181 H HW: 1K0 915 181 A
Component: J367-BDM H07 0180
Serial number: 40304F47221491365162


No fault code found.


-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 D HW: 3AA 907 273 D
Component: RDKBERU30 H09 0010
Serial number: 30000000008106
ASAM Dataset: EV_RDKBERU30 003012
ROD: EV_RDKBERU30_003.rod
VCID: 356194D394417F2721-8060


No fault code found.


-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:. 7N0-907-383.clb
Part No SW: 7N0 907 383 HW: 7N0 907 383
Component: Anhaenger H09 0120
Revision: 3I001003 Serial number: 00008160140260
Coding: 4106040001000000
Shop #: WSC 05314 000 00000
VCID: 73E56ACBD2B52117CF-8026


1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 6
Fault Frequency: 26
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 15:15:27




End-------------------------(Elapsed Time: 04:09)--------------------------


--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Address 44: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Address 01: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Address 01: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Address 03: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Address 03: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Chassis Type: 3C-VW46
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 69 72

VIN: Mileage: 207140km-128710miles
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFFB) Labels:. 03L-906-018-CFF.clb
Part No SW: 03L 906 018 PR HW: 03L 907 309 AE
Component: R4 2,0L EDC X28 4006
Revision: 41X28--- Serial number: 00000000000000 CVN: DE61F492
Coding: 00190012043501080000
Shop #: WSC 92521 052 00000
ASAM Dataset: EV_ECM20TDI01103L906018PR 003004
ROD: EV_ECM20TDI01103L906018PR.rod
VCID: 09192823A8394BC795-805C
VINID: 9E69EAAAA0D3A95540204046043A8F1A88


1 Fault Found:
4611 - Control Module Malfunction - DBW Throttle Monitoring
P1388 00 [036] - -
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 207141 km
Date: 2127.14.31
Time: 16:10:49


Engine RPM: 1200.00 /min
Normed load value: 19.6 %
Vehicle speed: 0 km/h
Coolant temperature: 53 °C
Intake air temperature: 21 °C
Ambient air pressure: 990 mbar
Voltage terminal 30: 12.600 V
Unlearning counter according OBD: 40
Speed regulation requested torque: -447.2 Nm
Accelerator pedal travel: 0.00 %
Accelerator pedal: sensor voltage 1: 0.0 mV
Accelerator pedal: sensor voltage 2: 0.0 mV
Control Module temperature: 11.8 °C
Outside temperature: 13.5 °C


Readiness: 0 0 0 0 1


-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 AP HW: 3AA 614 109 AP
Component: J104 C2 450M V40A 0030
Revision: --H07--- Serial number: 00000007626894
Coding: 0002992
Shop #: WSC 05311 000 00000
VCID: 7BF542EB3AE5695797-802E


1 Fault Found:
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
Freeze Frame:
Fault Status: 00101101
Fault Priority: 3
Fault Frequency: 1
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 16:11:30


Freeze Frame:
Speed: 0.0 km/h
Hex Value: 0x0000
Bin. Bits: 00000000 00000000
Voltage: 12.50 V
Bin. Bits: 00011111
Count: 229
Hex Value: 0x0000




-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 3AA 907 044 BT HW: 3AA 907 044 BT
Component: Climatronic H05 0505
Revision: 00001K02
Coding: 061400C803
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW46.rod
VCID: 03053A0B8A151197DF-8056


1 Fault Found:
13701376 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 10
Reset counter: 50
Mileage: 207141 km
Date: 2127.14.31
Time: 23:03:51




-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 3AA-937-087.clb
Part No SW: 3AA 937 087 P HW: 3AA 937 087 P
Component: BCM PQ47 H 422 0474
Revision: BB422001
Coding: 0008000000000000009800805400816403510088426D876064 80C7200041
Shop #: WSC 05311 000 00000
VCID: 479DEE1BF6ADFDB743-8012


Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 30101 26 0612
Coding: 00B795


Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 311013 05 54 0403
Coding: 2230ED


2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 6
Fault Frequency: 8
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 23:03:53


Freeze Frame:
Term 15 On
Voltage: 11.45 V
ON
ON
ON
OFF
OFF


03678 - Coordinator for Start-Stop Operation
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 6
Fault Frequency: 8
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2063.14.31
Time: 23:03:53


Freeze Frame:
Term 15 On
Voltage: 11.45 V
ON
ON
ON
OFF
OFF




-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 C HW: 7N0 919 475
Component: PARKHILFE 8K H06 0018
Revision: -------- Serial number: 28231329103692
Coding: 118002
Shop #: WSC 99999 1023 2097151
ASAM Dataset: EV_EPHVA18VW47X0000 001006
ROD: EV_EPHVA18VW47X0000.rod
VCID: 3F8DF6FBA67DB577FB-806A


No fault code found.


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 AA HW: 5N0 959 655 AA
Component: J234__108 VW10 HI 2518
Revision: 27019000 Serial number: 003L7PP2DZHJ
Coding: 0012344
Shop #: WSC 05311 000 00000
VCID: 7CF741F73FEB6E6F9E-8028


Subsystem 1 - Serial number: 6332MTS617962873


Subsystem 2 - Serial number: 6342MTS609662873


Subsystem 3 - Serial number: 6351HTS6JLLRECKR


Subsystem 4 - Serial number: 6361HTS69AJIFCKJ


Subsystem 5 - Serial number: 00000000000000000


Subsystem 6 - Serial number: 00000000000000000


No fault code found.


-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C9 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 016 0140
Revision: FF010042 Serial number: 20131008201503
Coding: 118A250000
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: 76E353DFC9C7343FE8-8022


Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H07 0022
Coding: E20000


No fault code found.


-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 980 N HW: 3AA 920 980 N
Component: KOMBI H04 0611
Serial number: 00000000000000
Coding: 461F00
Shop #: WSC 05314 115 12345
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod
VCID: 3F8DF6FBA67DB577FB-806A


1 Fault Found:
12648448 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 16
Reset counter: 50
Mileage: 207141 km
Date: 2025.02.21
Time: 23:03:51




-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AN HW: 7N0 907 530 AN
Component: J533 Gateway H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 462007
Shop #: WSC 05314 000 00000
VCID: 7CF741F7FFEB6E6F9E-8028


1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00110100
Fault Priority: 2
Fault Frequency: 18
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 23:03:53




-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: IMMO 043 0407
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: 387F9DE74B53824F3A-806C


Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380


No fault code found.


-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 G HW: 5N0 035 342 G
Component: SG EXT.PLAYER H19 0770
Revision: A1001003 Serial number: 7665337526
Coding: 020100
Shop #: WSC 05314 000 00000
VCID: 2B55B2AB4A0539D747-807E


No fault code found.


-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C8 035 279 G HW: 3C8 035 279 G
Component: RNS315-EU H76 0410
Serial number: VWZAZ2N0601260
Coding: 040004010400110000011002
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_RNS315EUV2UDS 001705
ROD: EV_RNS315EUV2UDS.rod
VCID: 2F6DA6BB761D45F76B-807A


Data carrier:
Subsystem 1 - Part No: 3AA 919 866
Component: EUR_W_V12 0078


1 Fault Found:
1048598 - Front Right Treble Speaker
B1064 13 [009] - Open Circuit
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 10
Mileage: 207141 km
Date: 2025.02.21
Time: 23:03:54




-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 0534
Revision: 12110009 Serial number: 0007695044
Coding: 0212B7
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: 356194D394417F2721-8060


Slave Driver:
Subsystem 1 - Part No SW: 3AA 959 704 A HW: 3AA 959 794 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 004 0503
Serial number: 00000003720677
Coding: 010290


1 Fault Found:
68108 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 50
Mileage: 207141 km
Date: 2025.02.21
Time: 00:00:45




-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 R
Component: EPS_ZFLS Kl. 195 3501
Revision: 00H22000
Shop #: WSC 02069 000 90108
VCID: 397998E370599B47C5-806C


No fault code found.


-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: KSG PQ47 ELV 043 0645
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 0191020052830E76340C94157C085FCE105C04
Shop #: WSC 05311 000 00000
VCID: 387F9DE74B53824F3A-806C


Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H05 1501


Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611


Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611


No fault code found.


-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 7N0 907 530 AN
Component: EZE_2 H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 050B0508
Shop #: WSC 05314 000 00000
VCID: 6FED66BBBE9D05F72B-803A


No fault code found.


-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0534
Revision: 14110009 Serial number: 0007704561
Coding: 0212B6
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: 366393DF8947743F28-8062


Slave Passenger:
Subsystem 1 - Part No SW: 3AA 959 703 A HW: 3AA 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0503
Serial number: 00000003721958
Coding: 010290


1 Fault Found:
68108 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 50
Mileage: 207141 km
Date: 2025.02.21
Time: 00:00:45




-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 H HW: 3AA 907 801 H
Component: J540 EPB4 VW-86594 0010
Revision: H19 Serial number: 00000001606578
Coding: 0022167
Shop #: WSC 05311 000 00000
VCID: 366393DF4147743F28-8062


4 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 41
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 15:15:26


Freeze Frame:
Voltage: 11.20 V
Count: 71
Speed: 0.0 km/h
Hex Value: 0x1263
Hex Value: 0x0001
Hex Value: 0x1010


03182 - Clutch Position Sensor (G476)
010 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 50
Time Indication: 0


Freeze Frame:
Voltage: 11.90 V
Count: 55
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010


01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
Freeze Frame:
Fault Status: 00101101
Fault Priority: 2
Fault Frequency: 5
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 00:00:28


Freeze Frame:
Voltage: 11.70 V
Count: 65
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010


01314 - Engine Control Module
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 00:00:31


Freeze Frame:
Voltage: 11.80 V
Count: 61
Speed: 0.0 km/h
Hex Value: 0x1273
Hex Value: 0x0001
Hex Value: 0x1010




-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 7N0 907 530 AN
Component: Batt.regelung H56 1642
Serial number: 131013F2000903
Coding: 330F1859
Shop #: WSC 05314 000 00000
VCID: 71E960C3A8A913073D-8024


Subsystem 1 - Part No SW: 1K0 915 181 H HW: 1K0 915 181 A
Component: J367-BDM H07 0180
Serial number: 40304F47221491365162


No fault code found.


-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 D HW: 3AA 907 273 D
Component: RDKBERU30 H09 0010
Serial number: 30000000008106
ASAM Dataset: EV_RDKBERU30 003012
ROD: EV_RDKBERU30_003.rod
VCID: 356194D394417F2721-8060


No fault code found.


-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:. 7N0-907-383.clb
Part No SW: 7N0 907 383 HW: 7N0 907 383
Component: Anhaenger H09 0120
Revision: 3I001003 Serial number: 00008160140260
Coding: 4106040001000000
Shop #: WSC 05314 000 00000
VCID: 73E56ACBD2B52117CF-8026


1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 6
Fault Frequency: 26
Reset counter: 50
Mileage: 207141 km
Time Indication: 0
Date: 2019.07.15
Time: 15:15:27




End-------------------------(Elapsed Time: 03:24)--------------------------


--------------------------------------------------------------------------------


Fault Codes cleared again at this point but I obviously forgot to save that info (or didn't realise it wouldn't be saved)
Also, engine no longer running as I stopped it to see if I got different codes / results.


--------------------------------------------------------------------------------




Gateway Installation List: 7N0 907 530 AN


01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000


--------------------------------------------------------------------------------
--------------------------------------------------------------------------------




Chassis Type: 3C-VW46
Scan: 01 03 08 09 10 15 16 17 19 25 2E 37 42 44 46 4F 52 53 56 61
62 65 69 72

VIN: Mileage: 207140km-128710miles
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFFB) Labels:. 03L-906-018-CFF.clb
Part No SW: 03L 906 018 PR HW: 03L 907 309 AE
Component: R4 2,0L EDC X28 4006
Revision: 41X28--- Serial number: 00000000000000 CVN: DE61F492
Coding: 00190012043501080000
Shop #: WSC 92521 052 00000
ASAM Dataset: EV_ECM20TDI01103L906018PR 003004
ROD: EV_ECM20TDI01103L906018PR.rod
VCID: 09192823A8394BC795-805C
VINID: 9E69EAAAA0D3A95540204046043A8F1A88


No fault code found.
Readiness: 0 0 0 0 1


-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 3AA-614-109.clb
Part No SW: 3AA 614 109 AP HW: 3AA 614 109 AP
Component: J104 C2 450M V40A 0030
Revision: --H07--- Serial number: 00000007626894
Coding: 0002992
Shop #: WSC 05311 000 00000
VCID: 7BF542EB3AE5695797-802E


No fault code found.


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 3AA 907 044 BT HW: 3AA 907 044 BT
Component: Climatronic H05 0505
Revision: 00001K02
Coding: 061400C803
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW46.rod
VCID: 03053A0B8A151197DF-8056


No fault code found.


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 3AA-937-087.clb
Part No SW: 3AA 937 087 P HW: 3AA 937 087 P
Component: BCM PQ47 H 422 0474
Revision: BB422001
Coding: 0008000000000000009800805400816403510088426D876064 80C7200041
Shop #: WSC 05311 000 00000
VCID: 479DEE1BF6ADFDB743-8012


Subsystem 1 - Part No: 3AC 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 30101 26 0612
Coding: 00B795


Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 311013 05 54 0403
Coding: 2230ED


No fault code found.


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 3AE-919-475.clb
Part No SW: 3AE 919 475 C HW: 7N0 919 475
Component: PARKHILFE 8K H06 0018
Revision: -------- Serial number: 28231329103692
Coding: 118002
Shop #: WSC 99999 1023 2097151
ASAM Dataset: EV_EPHVA18VW47X0000 001006
ROD: EV_EPHVA18VW47X0000.rod
VCID: 3F8DF6FBA67DB577FB-806A


No fault code found.


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 AA HW: 5N0 959 655 AA
Component: J234__108 VW10 HI 2518
Revision: 27019000 Serial number: 003L7PP2DZHJ
Coding: 0012344
Shop #: WSC 05311 000 00000
VCID: 7CF741F73FEB6E6F9E-8028


Subsystem 1 - Serial number: 6332MTS617962873


Subsystem 2 - Serial number: 6342MTS609662873


Subsystem 3 - Serial number: 6351HTS6JLLRECKR


Subsystem 4 - Serial number: 6361HTS69AJIFCKJ


Subsystem 5 - Serial number: 00000000000000000


Subsystem 6 - Serial number: 00000000000000000


No fault code found.


-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 3C0-953-569.clb
Part No SW: 3C9 953 501 BN HW: 5K0 953 569 AB
Component: LENKS.MODUL 016 0140
Revision: FF010042 Serial number: 20131008201503
Coding: 118A250000
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: 76E353DFC9C7343FE8-8022


Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H07 0022
Coding: E20000


No fault code found.


-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 3C8-920-xxx-17.clb-SRI1
Part No SW: 3AA 920 980 N HW: 3AA 920 980 N
Component: KOMBI H04 0611
Serial number: 00000000000000
Coding: 461F00
Shop #: WSC 05314 115 12345
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
ROD: EV_Kombi_UDS_VDD_RM09_004_VW46.rod
VCID: 3F8DF6FBA67DB577FB-806A


No fault code found.


-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AN HW: 7N0 907 530 AN
Component: J533 Gateway H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 462007
Shop #: WSC 05314 000 00000
VCID: 7CF741F7FFEB6E6F9E-8028


No fault code found.


-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: IMMO 043 0407
Revision: 00043000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: 387F9DE74B53824F3A-806C


Subsystem 1 - Part No: 3C0 905 861 J
Component: ELV 029 0380
3C0905861J ELV 029 0380


No fault code found.


-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 G HW: 5N0 035 342 G
Component: SG EXT.PLAYER H19 0770
Revision: A1001003 Serial number: 7665337526
Coding: 020100
Shop #: WSC 05314 000 00000
VCID: 2B55B2AB4A0539D747-807E


No fault code found.


-------------------------------------------------------------------------------
Address 37: Navigation (J794) Labels:| 1K0-035-27x-37.clb
Part No SW: 3C8 035 279 G HW: 3C8 035 279 G
Component: RNS315-EU H76 0410
Serial number: VWZAZ2N0601260
Coding: 040004010400110000011002
Shop #: WSC 00015 115 00000
ASAM Dataset: EV_RNS315EUV2UDS 001705
ROD: EV_RNS315EUV2UDS.rod
VCID: 2F6DA6BB761D45F76B-807A


Data carrier:
Subsystem 1 - Part No: 3AA 919 866
Component: EUR_W_V12 0078


1 Fault Found:
1048598 - Front Right Treble Speaker
B1064 13 [009] - Open Circuit
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 10
Mileage: 207141 km
Date: 2025.02.21
Time: 16:16:38




-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 701 A HW: 3C0 959 793 C
Component: TUER-SG FT 002 0534
Revision: 12110009 Serial number: 0007695044
Coding: 0212B7
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04001
ROD: EV_TSGFPQ35BRFVW46X_VW32.rod
VCID: 356194D394417F2721-8060


Slave Driver:
Subsystem 1 - Part No SW: 3AA 959 704 A HW: 3AA 959 794 Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 004 0503
Serial number: 00000003720677
Coding: 010290


No fault code found.


-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 R
Component: EPS_ZFLS Kl. 195 3501
Revision: 00H22000
Shop #: WSC 02069 000 90108
VCID: 397998E370599B47C5-806C


No fault code found.


-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 3C0-959-433-46.clb
Part No SW: 3AA 959 433 B HW: 3AA 959 433 B
Component: KSG PQ47 ELV 043 0645
Revision: 00043000 Serial number: VWZCZ000000000
Coding: 0191020052830E76340C94157C085FCE105C04
Shop #: WSC 05311 000 00000
VCID: 387F9DE74B53824F3A-806C


Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H05 1501


Subsystem 2 - Part No: 3C0 951 171 C
Component: Neigungssensor 004 0611


Subsystem 3 - Part No: 3C0 951 171 C
Component: Innenraumueberw.004 0611


No fault code found.


-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 7N0 907 530 AN
Component: EZE_2 H56 1642
Revision: H56 Serial number: 131013F2000903
Coding: 050B0508
Shop #: WSC 05314 000 00000
VCID: 6FED66BBBE9D05F72B-803A


Subsystem 1 - Part No SW: 7N0 959 591 B HW: 7N0 959 591 B
Component: J245EE04SKB03 H03 0090
Serial number: 0123456789ABCDEFGHIJ


Subsystem 2 - Part No SW: 7N0 959 591 B HW: 7N0 959 591 B
Component: J394EE04SKB03 H03 0090
Serial number: 0123456789ABCDEFGHIJ


Subsystem 3 - Part No SW: 3AA 919 204 A HW: 3AA 919 204 A
Component: Analoguhr 004 0004


No fault code found.


-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3AA 959 702 A HW: 3C0 959 792 C
Component: TUER-SG BT 002 0534
Revision: 14110009 Serial number: 0007704561
Coding: 0212B6
Shop #: WSC 05311 115 00000
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW32.rod
VCID: 366393DF8947743F28-8062


Slave Passenger:
Subsystem 1 - Part No SW: 3AA 959 703 A HW: 3AA 959 795 Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 004 0503
Serial number: 00000003721958
Coding: 010290


No fault code found.


-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 H HW: 3AA 907 801 H
Component: J540 EPB4 VW-86594 0010
Revision: H19 Serial number: 00000001606578
Coding: 0022167
Shop #: WSC 05311 000 00000
VCID: 366393DF4147743F28-8062


No fault code found.


-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840) Labels:. 1K0-907-534.clb
Part No SW: 7N0 907 534 HW: 7N0 907 530 AN
Component: Batt.regelung H56 1642
Serial number: 131013F2000903
Coding: 330F1859
Shop #: WSC 05314 000 00000
VCID: 71E960C3A8A913073D-8024


Subsystem 1 - Part No SW: 1K0 915 181 H HW: 1K0 915 181 A
Component: J367-BDM H07 0180
Serial number: 40304F47221491365162


No fault code found.


-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3AA-907-273.clb
Part No SW: 3AA 907 273 D HW: 3AA 907 273 D
Component: RDKBERU30 H09 0010
Serial number: 30000000008106
ASAM Dataset: EV_RDKBERU30 003012
ROD: EV_RDKBERU30_003.rod
VCID: 356194D394417F2721-8060


No fault code found.


-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:. 7N0-907-383.clb
Part No SW: 7N0 907 383 HW: 7N0 907 383
Component: Anhaenger H09 0120
Revision: 3I001003 Serial number: 00008160140260
Coding: 4106040001000000
Shop #: WSC 05314 000 00000
VCID: 73E56ACBD2B52117CF-8026


No fault code found.


End-------------------------(Elapsed Time: 03:24)--------------------------

[Crasher]

I,would start by replacing the 100 relay at position four with the revised 644 type, part number 4H0 951 253

[VolksPhil]

Thanks, I'll get one on order.

Today's Update: Without doing anything to my car since yesterday, I tried to start it - started fine, so after about 30-60 seconds, I stopped the engine and tried again - started fine. So then as I replaced items (ECU plug securing strap, ECU into 'fitted' position, battery cover, pretty much any item I had removed), I tried a re-start - and every time it started! I then went for a tentative drive -all seemed good (with one slight exception being my Cruise Control but that is not related to this fault) but I waited until I got home before stopping the engine once more, then tried restarting it again - yup, it started fine.

So, nothing has been replaced, a few plugs / socket / wires have been jiggled and now it seems ok - but of course, confidence is slightly lacking at the moment....

I'll start a new thread about my Cruise Control - it's a sticky switch, so nothing to do with any of this.